hit counter script
Toro Recycler 20373 Operator's Manual
  1. Manuals
  2. Brands
  3. Toro Manuals
  4. Lawn Mower
  5. Recycler 20373
  6. Operator's manual
Toro Recycler 20373 Operator's Manual

Toro Recycler 20373 Operator's Manual

22in serial no. 400000000 and up
Hide thumbs Also See for Recycler 20373:
Table of Contents

Advertisement

Quick Links

22in Recycler
Model No. 20373—Serial No. 400000000 and Up

Introduction

This rotary-blade, walk-behind lawn mower is intended to
be used by residential homeowners. It is designed primarily
for cutting grass on well-maintained lawns on residential
properties. It is not designed for cutting brush or for
agricultural uses.
Read this information carefully to learn how to operate and
maintain your product properly and to avoid injury and
product damage. You are responsible for operating the
product properly and safely.
You may contact Toro directly at www.Toro.com for product
and accessory information, help finding a dealer, or to register
your product.
Whenever you need service, genuine Toro parts, or additional
information, contact an Authorized Service Dealer or Toro
Customer Service and have the model and serial numbers of
your product ready.
Figure 1
model and serial numbers on the product.
1. Model and serial number plate
Write the product model and serial numbers in the space
below:
Model No.
Serial No.
This manual identifies potential hazards and has safety
messages identified by the safety-alert symbol
which signals a hazard that may cause serious injury or death
if you do not follow the recommended precautions.
© 2016—The Toro® Company
8111 Lyndale Avenue South
Bloomington, MN 55420
®
identifies the location of the
Figure 1
(Figure
Register at www.Toro.com.
Lawn Mower
1. Safety-alert symbol
This manual uses 2 words to highlight information.
Important calls attention to special mechanical information
and Note emphasizes general information worthy of special
attention.
This product contains a chemical or chemicals
known to the State of California to cause cancer,
birth defects, or reproductive harm.
The engine exhaust from this product
contains chemicals known to the State of
California to cause cancer, birth defects,
or other reproductive harm.
It is a violation of California Public Resource Code
Section 4442 or 4443 to use or operate the engine on any
forest-covered, brush-covered, or grass-covered land unless
the engine is equipped with a spark arrester, as defined in
Section 4442, maintained in effective working order or the
engine is constructed, equipped, and maintained for the
prevention of fire.
g195421
This spark ignition system complies with Canadian ICES-002.
Net Torque: The gross or net torque of this engine was
laboratory rated by the engine manufacturer in accordance
with the Society of Automotive Engineers (SAE) J1940.
As configured to meet safety, emission, and operating
requirements, the actual engine torque on this class of mower
will be significantly lower. Go to www.Toro.com to view
specifications on your mower model.
Important: If you are using this machine above 1500 m
(5,000 ft) for a continuous period, ensure that the High
Altitude Kit has been installed so that the engine meets
CARB/EPA emission regulations. The High Altitude
Kit increases engine performance while preventing
spark-plug fouling, hard starting, and increased
2),
emissions. Once you have installed the kit, attach
the high-altitude label next to the serial decal on the
machine. Contact any Authorized Toro Service Dealer
Form No. 3408-966 Rev A
Operator's Manual
Figure 2
WARNING
CALIFORNIA
Proposition 65 Warning
Original Instructions (EN)
All Rights Reserved *3408-966* A
Printed in the USA
g000502

Advertisement

Table of Contents
loading

Related Manuals for Toro Recycler 20373

Summary of Contents for Toro Recycler 20373

  • Page 1: Introduction

    You are responsible for operating the product properly and safely. WARNING You may contact Toro directly at www.Toro.com for product and accessory information, help finding a dealer, or to register CALIFORNIA your product. Proposition 65 Warning...

  • Page 2: Table Of Contents

    After Operation ............15 label for your machine. To locate a dealer convenient to After Operating Safety ..........15 you, access our website at www.Toro.com or contact our Cleaning under the Machine........15 Toro Customer Care Department at the number(s) listed Folding the Handle ..........16 in your Emission Control Warranty Statement.

  • Page 3: Safety And Instructional Decals

    Safety and Instructional Decals Safety decals and instructions are easily visible to the operator and are located near any area of potential danger. Replace any decal that is damaged or missing. decaloemmarkt Manufacturer's Mark 1. Indicates the blade is identified as a part from the original machine manufacturer.
  • Page 4 decal131-4514b 131-4514 1. Warning—read the Operator's Manual. 2. Cutting/dismemberment hazard of hand or foot, mower blade—stay away from moving parts; keep all guards and shields in place. 3. Cutting/dismemberment hazard of hand or foot, mower blade—disconnect the spark-plug wire and read the instructions before servicing or performing maintenance.

  • Page 5: Setup

    Setup Note: The pins do not show through the holes in the handle ends when the handle is in the folded position. Important: Remove and discard the protective plastic 3. Unfold the handle to the operating position by rotating it rearward (Figure sheet that covers the engine and any other plastic or wrapping on the machine.

  • Page 6: Filling The Engine With Oil

    wait 3 minutes, and repeat steps through until the oil level on the dipstick is at the correct level. • If the oil level on the dipstick is too high, drain the excess oil until the oil level on the dipstick is Filling the Engine with Oil at the correct level;...

  • Page 7: Assembling The Grass Bag

    Assembling the Grass Bag No Parts Required Procedure 1. Slip the grass bag over the frame as shown in Figure g027257 g027257 Figure 9 g027258 g027258 Figure 10 1. Handle 3. Grass bag 2. Frame 3. Hook the top and side channels of the bag onto the top Note: Do not slip the bag over the handle and sides of the frame, respectively (Figure...

  • Page 8: Product Overview

    Product Overview Operation Before Operation Before Operation Safety General Safety • Become familiar with the safe operation of the equipment, operator controls, and safety signs. • Check that all guards and safety devices, such as doors and/or grass catchers, are in place and working properly. •...

  • Page 9: Filling The Fuel Tank

    Filling the Fuel Tank Checking the Engine-Oil Level • For best results, use only clean, fresh, unleaded gasoline Service Interval: Before each use or daily with an octane rating of 87 or higher ((R+M)/2 rating 1. Move the machine to a level surface. method).

  • Page 10: Adjusting The Handle Height

    Adjusting the Handle Height You can raise or lower the handle in 1 of 2 positions that is more comfortable for you (Figure 15). g195422 Figure 15 1. Loosen both handle knobs until you can push the g195426 Figure 16 square edges of the carriage bolts out of the square holes in the handle brackets.

  • Page 11: During Operation

    • Use accessories and attachments approved by the The g005046 Figure 19 Toro® Company only. Slope Safety Note: If the machine does not freely roll backward after • self-propelling, stop walking, hold your hands in place, and Mow across the face of slopes;...

  • Page 12: Shutting Off The Engine

    Shutting Off the Engine 3. Hold the blade-control bar against the handle (Figure 23). To shut off the engine, press and hold the engine-shutoff button (Figure 21) until the engine shuts off. g003125 Figure 23 G017317 g017317 Disengaging the Blade Figure 20 1.

  • Page 13: Recycling The Clippings

    Installing the Grass Bag Note: If the bag does not immediately deflate, the blade is still rotating. The blade-brake clutch may be 1. Raise and hold up the rear door (Figure 25). deteriorating and, if ignored, could result in an unsafe operating condition.

  • Page 14: Side-Discharging The Clippings

    and the surrounding opening (Figure 27) before you move the bag-on-demand lever from 1 position to another. g195423 Figure 27 1. Clean here Side-Discharging the Clippings Use side-discharging for cutting very tall grass. If the grass bag is on the machine and the bag-on-demand lever is in the bagging position, move the lever to the recycling position;...

  • Page 15: Operating Tips

    • Replace the blade when necessary with a Toro replacement blade. Hauling Safety • Use care when loading or unloading the machine.

  • Page 16: Folding The Handle

    Important: Route the cables to the outside of the handle knobs as you fold the handle. g195429 Figure 29 1. Washout port 6. Turn the water on. g032869 Figure 30 7. Start the engine and run it until there are no more clippings that come out from under the machine.

  • Page 17: Recommended Maintenance Schedule(S)

    Recommended Maintenance Schedule(s) Maintenance Service Maintenance Procedure Interval • Change the engine oil. After the first 5 hours • Check the engine-oil level. • Ensure that the engine shuts off within 3 seconds after releasing the blade-control bar. Before each use or daily •...

  • Page 18: Servicing The Air Filter

    Servicing the Air Filter Changing the Engine Oil Service Interval: After the first 5 hours Service Interval: Yearly Yearly 1. Press down on the latch tabs on top of the air-filter cover (Figure 33). Note: Run the engine a few minutes before changing the oil to warm it.

  • Page 19: Replacing The Blade

    6. Carefully pour about 3/4 of the engine capacity of oil into the oil-fill tube. 7. Wait about 3 minutes for the oil to settle in the engine. 8. Wipe the dipstick clean with a clean cloth. 9. Insert the dipstick into the oil-fill tube, but do not screw it in, then remove the dipstick.

  • Page 20: Adjusting The Self-Propel Drive

    Storage removed. 1. On the last refueling of the year, add fuel stabilizer 10. Install the blade and the stiffener that you previously (such as Toro Premium Fuel Treatment) to the fuel. removed (Figure 37). 2. Dispose of any unused fuel properly. Recycle it 11.
  • Page 21 Notes:...
  • Page 22 Notes:...
  • Page 23 Notes:...
  • Page 24 Countries Other than the United States or Canada This warranty is not valid in Mexico. Customers who have purchased Toro products exported from the United States or Canada should contact their Toro Distributor (Dealer) to obtain guarantee policies for your country, province, or state. If for any reason you are dissatisfied with your Distributor's service or have difficulty obtaining guarantee information, contact the Toro importer.

Table of Contents