hit counter script
Toro 20330 - Low Wheel Walk Power Mower Operator's Manual
  1. Manuals
  2. Brands
  3. Toro Manuals
  4. Lawn Mower
  5. 20330 - Low Wheel Walk Power Mower
  6. Operator's manual
Toro 20330 - Low Wheel Walk Power Mower Operator's Manual

Toro 20330 - Low Wheel Walk Power Mower Operator's Manual

22in recycler lawn mower
Hide thumbs Also See for 20330 - Low Wheel Walk Power Mower:
Table of Contents

Advertisement

Available languages

Available languages

Quick Links

See also: Service Manual
22in Recycler
Model No. 20330—Serial No. 290000001 and Up
Model No. 20330C—Serial No. 290000001 and Up
Model No. 20331—Serial No. 290000001 and Up
Model No. 20331C—Serial No. 290000001 and Up
Model No. 20350—Serial No. 290000001 and Up
Model No. 20351—Serial No. 290000001 and Up
Replacement parts are available from an Authorized Service Dealer or at www.shoptoro.com.
Introduction
Read this information carefully to learn how to operate
and maintain your product properly and to avoid injury
and product damage. You are responsible for operating
the product properly and safely.
You may contact Toro directly at www.Toro.com for
product and accessory information, help finding a
dealer, or to register your product.
Whenever you need service, genuine Toro parts, or
additional information, contact an Authorized Service
Dealer or Toro Customer Service and have the model
and serial numbers of your product ready. Figure 1
identifies the location of the model and serial numbers
on the product.
Figure 1
1. Model and serial number plate
Write the product model and serial numbers in the space
below:
Model No.
Serial No.
This manual identifies potential hazards and has
safety messages identified by the safety alert symbol
© 2008—The Toro® Company
8111 Lyndale Avenue South
Bloomington, MN 55420
Lawn Mower
®
(Figure 2), which signals a hazard that may cause serious
injury or death if you do not follow the recommended
precautions.
1. Safety alert symbol
This manual uses 2 words to highlight information.
Important calls attention to special mechanical
information and Note emphasizes general information
worthy of special attention.
The engine exhaust from this product
contains chemicals known to the State of
California to cause cancer, birth defects,
Important: This engine is not equipped with a
spark arrester muffler. It is a violation of California
Public Resource Code Section 4442 to use or operate
the engine on any forest-covered, brush-covered, or
grass-covered land. Other states or federal areas
may have similar laws.
This spark ignition system complies with Canadian
ICES-002.
The enclosed Engine Owner's Manual is supplied
for information regarding the US Environmental
Protection Agency (EPA) and the California
Emission Control Regulation of emission systems,
Register at www.Toro.com.
Form No. 3360-854 Rev B
Operator's Manual
Figure 2
Warning
CALIFORNIA
Proposition 65 Warning
or other reproductive harm.
Original Instructions (EN)
Printed in the USA
All Rights Reserved

Advertisement

Table of Contents
loading

Related Manuals for Toro 20330 - Low Wheel Walk Power Mower

Summary of Contents for Toro 20330 - Low Wheel Walk Power Mower

  • Page 1 This manual uses 2 words to highlight information. additional information, contact an Authorized Service Important calls attention to special mechanical Dealer or Toro Customer Service and have the model information and Note emphasizes general information and serial numbers of your product ready. Figure 1 worthy of special attention.

  • Page 2: General Operation

    maintenance, and warranty. Replacements may be • Never direct discharged material toward anyone. ordered through the engine manufacturer. Avoid discharging material against a wall or obstruction. Material may ricochet back toward For models with stated engine horsepower, the gross the operator. Stop the blade when crossing gravel horsepower of the engine was laboratory rated by the surfaces.

  • Page 3: Safe Handling Of Gasoline

    Children Tragic accidents can occur if the operator is not alert to Exhaust contains carbon monoxide, an the presence of children. Children are often attracted to odorless, deadly poison that can kill you. the machine and the mowing activity. Never assume that children will remain where you last saw them.

  • Page 4: Safety And Instructional Decals

    Safety and Instructional Decals Important: Safety and instruction decals are located near areas of potential danger. Replace damaged decals. Setup Important: Remove and discard the protective plastic sheet that covers the engine. Manufacturer’s Mark 1. Indicates the blade is identified as a part from the original machine manufacturer.

  • Page 5: Filling The Engine With Oil

    2. Filling the Engine with Oil Product Overview Procedure Your mower does not come with oil in the engine, but it does come with a bottle of oil. 1. Remove the dipstick (Figure 4). Figure 5 7. Recoil start handle 1.

  • Page 6: Filling The Fuel Tank

    Checking the Engine Oil Level Operation Service Interval: Before each use or daily Filling the Fuel Tank 1. Remove the dipstick, wipe it clean, and fully install the dipstick (Figure 8). Gasoline is extremely flammable and explosive. A fire or explosion from gasoline can burn you and others.

  • Page 7: Starting The Engine

    Starting the Engine Adjust the cutting height as desired. Set the front wheels to the same height as the rear wheels. 1. Hold the blade control bar against the handle (Figure 10). Note: To raise the mower, move all the cutting height levers rearward.

  • Page 8: Stopping The Engine

    Check the grass bag frequently. If it is damaged, install a new Toro replacement bag. If the side discharge chute is on the mower, remove it (refer to Removing the Side Discharge Chute) before Figure 12 bagging the clippings.

  • Page 9: Side-Discharging The Clippings

    (Figure 13). • For best performance, install a new blade before the cutting season begins. • Replace the blade when necessary with a Toro replacement blade. Cutting Grass • Cut only about a third of the grass blade at a time.

  • Page 10: Cutting Leaves

    – Walk at a slower pace while mowing. – Raise the cutting height on your mower. – Cut the grass more frequently. – Overlap cutting swaths instead of cutting a full swath with each pass. – Set the cutting height on the front wheels one notch lower than the rear wheels.

  • Page 11: Recommended Maintenance Schedule(S)

    • Refer to your engine operator’s manual for any additional yearly maintenance procedures. Important: Refer to your engine operator’s manual for additional maintenance procedures. Note: Replacement parts are available from an Authorized Service Dealer (go to www.toro.com to find the nearest dealer) or at www.shoptoro.com. Preparing for Maintenance tip the mower prior to running out of fuel, use a hand fuel pump to remove the fuel.

  • Page 12: Replacing The Air Filter

    Replacing the Air Filter Service Interval: Every 25 hours 1. Use a screw driver to open the air filter cover (Figure 15). Figure 15 Figure 17 1. Dipstick 2. Replace the air filter (Figure 16). 3. Tip the mower onto its side with the air filter up to drain the used oil out through the oil fill tube (Figure 18).

  • Page 13: Replacing The Blade

    Replacing the Blade Service Interval: Yearly Important: You will need a torque wrench to install the blade properly . If you do not have a torque wrench or are uncomfortable performing this procedure, contact an Authorized Service Dealer. Examine the blade whenever you run out of gasoline. If the blade is damaged or cracked, replace it immediately.

  • Page 14: Cleaning The Mower

    Adjusting the Self-propel Drive Cleaning the Mower Cable Service Interval: Before each use or daily Whenever you install a new self-propel cable or if the self-propel drive is out of adjustment, adjust the self-propel drive cable. The mower may dislodge material from under 1.

  • Page 15: Folding The Handle

    Folding the Handle Storage Store the mower in a cool, clean, dry place. Folding or unfolding the handle improperly can Preparing the Mower for damage the cables, causing an unsafe operating Storage condition. • Do not damage the cables when folding or unfolding the handle.
  • Page 16 Instructions for Obtaining Warranty Service If you think that your Toro Product contains a defect in materials or workmanship, or if a normal, able-bodied adult can no longer start your product’s engine in one or two pulls, follow this procedure 1.
  • Page 17 Servicio Técnico Autorizado o con Asistencia al Cliente Importante llama la atención sobre información Toro, y tenga a mano los números de modelo y serie mecánica especial, y Nota resalta información general de su producto. Figura 1 identifica la ubicación de los que merece una atención especial.

  • Page 18: Operación General

    El Manual del propietario del motor adjunto • Despeje la zona de objetos tales como piedras, ofrece información sobre las normas de la U.S. alambres, juguetes, etc., que podrían ser arrojados Environmental Protection Agency (EPA) y de la por la cuchilla. Permanezca detrás del manillar California Emission Control Regulation sobre cuando el motor está...

  • Page 19: Manejo Seguro De La Gasolina

    especial. Si usted no se siente con confianza en una llama piloto, por ejemplo en un calentador de agua pendiente, no la siegue. u otro electrodoméstico. • Siegue de través las cuestas y pendientes, nunca hacia • No llene nunca los recipientes dentro de un vehículo arriba o hacia abajo.

  • Page 20: Pegatinas De Seguridad E Instrucciones

    masa con él contra el motor para evitar un arranque • No cambie los ajustes del regulador del motor ni accidental. haga funcionar el motor a una velocidad excesiva. • Compruebe frecuentemente los componentes del • Revise o sustituya las pegatinas de seguridad e recogedor y el protector de descarga y sustitúyalos instrucciones cuando sea necesario.

  • Page 21: Montaje

    Montaje 2. Llenado del cárter de aceite Importante: Retire y deseche la hoja protectora de Procedimiento plástico que cubre el motor. El cortacésped se suministra sin aceite en el motor, pero incluye una botella de aceite. 1. Instalación del agarradero 1.

  • Page 22: Operación

    El producto Operación Cómo llenar el depósito de combustible La gasolina es altamente inflamable y explosiva. Un incendio o una explosión provocado(a) por la gasolina puede causarle quemaduras a usted y a otras personas. • Para evitar que una carga estática incendie la gasolina, coloque el recipiente y/o el cortacésped directamente sobre el suelo antes de repostar, no en un vehículo o sobre...

  • Page 23: Ajuste De La Altura De Corte

    Ajuste de la altura de corte Al ajustar la altura de corte, usted podría tocar la cuchilla en movimiento, lo que podría causarle graves lesiones. • Pare el motor y espere a que se detengan todas las piezas en movimiento. •...

  • Page 24: Cómo Arrancar El Motor

    Compruebe frecuentemente la bolsa de recortes. Si está dañada, instale una bolsa de recambio Toro nueva. Si el conducto de descarga lateral está instalado en el Figura 11 cortacésped, retírelo (consulte Cómo retirar el conducto 1.
  • Page 25 2. Instale la bolsa de recortes, asegurándose de que los pasadores de la bolsa descansan en las muescas del manillar (Figura 12). La cuchilla está muy afilada; cualquier contacto con la cuchilla puede causar lesiones personales 3. Baje el deflector trasero. graves.

  • Page 26: Consejos De Operación

    • Sustituya la cuchilla cuando sea preciso por una cuchilla de repuesto Toro. Cómo cortar la hierba • Corte solamente un tercio de la hoja de hierba cada vez. No corte con un ajuste inferior a 54 mm (2-1/8 pulgadas) a menos que la hierba sea escasa, o a finales del otoño cuando el ritmo de crecimiento de...

  • Page 27: Calendario Recomendado De Mantenimiento

    Importante: Consulte en el Manual del operador del motor procedimientos adicionales de mantenimiento. Nota: Puede adquirir piezas de repuesto en un Servicio Técnico Autorizado (vaya a www.toro.com para encontrar el distribuidor más cercano) o en www.shoptoro.com. Preparación para el mantenimiento 1.

  • Page 28: Cambio Del Filtro De Aire

    Figura 16 Figura 14 3. Coloque la tapa. 3. Después de realizar el/los procedimiento(s) de Cómo cambiar el aceite del mantenimiento, conecte el cable de la bujía a la bujía. motor Importante: Antes de inclinar el cortacésped para cambiar el aceite o sustituir la cuchilla, Intervalo de mantenimiento: Después de las primeras deje que se vacíe el depósito de combustible 5 horas...
  • Page 29 Figura 18 4. Vierta lentamente aceite en el tubo de llenado hasta que el nivel llegue a la marca "Full" (lleno) de la varilla (Figura 17). No llene demasiado. Figura 19 (Capacidad máxima: 0,59 l (20 onzas), tipo: SAE 30, aceite detergente con clasificación de servicio API SF, SG, SH, SJ, SL o superior.) 4.
  • Page 30 Limpieza del cortacésped toda su fuerza a la llave y apriete el perno firmemente. Será muy difícil apretar este perno Intervalo de mantenimiento: Cada vez que se utilice demasiado. o diariamente Ajuste del cable de la transmisión autopropulsada El cortacésped puede soltar material de debajo Cada vez que instale un nuevo cable de la transmisión de la carcasa.
  • Page 31 9. Arranque el motor y hágalo funcionar durante unos 8. Instale la bujía sin apretarla. minutos para que se seque la carcasa y evitar que se 9. Apriete todos los pernos, tuercas y tornillos. oxide. 10. Espere a que se enfríe el motor antes de guardar el Cómo plegar el manillar cortacésped en un lugar cerrado.
  • Page 32 Instrucciones para obtener asistencia bajo la garantía Si usted cree que su Producto Toro tiene un defecto de materiales o mano de obra, o si un adulto de capacidad normal ya no puede arrancar el motor de su producto con uno o dos intentos, siga este procedimiento: 1.

This manual is also suitable for:

Recycler 20330cRecycler 20331Recycler 20331cRecycler 20350Recycler 20351Recycler 20330

Table of Contents