hit counter script
Sony DSX-MS60 Service Manual
  1. Manuals
  2. Brands
  3. Sony Manuals
  4. Car Receiver
  5. DSX-MS60
  6. Service manual
Sony DSX-MS60 Service Manual

Sony DSX-MS60 Service Manual

Hide thumbs Also See for DSX-MS60:
Table of Contents

Advertisement

Quick Links

SERVICE MANUAL
Ver. 1.0 2010.12
• This model is not equipped with a mechanism deck.
FOR UNITED STATES CUSTOMERS. NOT
APPLICABLE IN CANADA, INCLUDING
IN THE PROVINCE OF QUEBEC.
POUR LES CONSOMMATEURS AUX
ÉTATS-UNIS. NON APPLICABLE AU
CANADA, Y COMPRIS LA PROVINCE DE
QUÉBEC.
AUDIO POWER SPECIFICATIONS
CEA2006 Standard
Power Output: 17 Watts RMS
4 Ohms < 1% THD+N
SN Ratio: 80 dBA
(reference: 1 Watt into 4 Ohms)
9-893-049-01
Sony Corporation
2010L05-1
©
2010.12
Published by Sony Techno Create Corporation

SPECIFICATIONS

Tuner section
FM
Tuning range:
87.5 – 108.0 MHz (at 50 kHz step)
87.5 – 107.9 MHz (at 200 kHz step)
FM tuning interval: 50 kHz/200 kHz switchable
Antenna (aerial) terminal:
External antenna (aerial) connector
Intermediate frequency: 150 kHz
Usable sensitivity: 10 dBf
Selectivity: 75 dB at 400 kHz
Signal-to-noise ratio: 70 dB (mono)
Separation: 40 dB at 1 kHz
4 at
Frequency response: 20 – 15,000 Hz
AM
Tuning range:
531 – 1,602 kHz (at 9 kHz step)
530 – 1,710 kHz (at 10 kHz step)
AM tuning interval: 9 kHz/10 kHz switchable
Antenna (aerial) terminal:
External antenna (aerial) connector
Intermediate frequency: 25 kHz
Sensitivity: 26 μV
USB Player section
Interface: USB (Full-speed)
Maximum current: 500 mA
Power amplifier section
Output: Speaker outputs
Speaker impedance: 4 – 8 ohms
Maximum power output: 52 W × 4 (at 4 ohms)
DSX-MS60
Canadian Model
General
Outputs:
Audio outputs terminal (front, sub/rear switchable)
Power antenna (aerial) relay control terminal
Power amplifier control terminal
Inputs:
BUS control input terminal
BUS audio input terminal
Remote controller input terminal
Antenna (aerial) input terminal
Telephone ATT control terminal
Illumination control terminal
AUX input jack (stereo mini jack)
USB signal input connector
Tone controls:
Low: ±10 dB at 60 Hz (XPLOD)
Mid: ±10 dB at 1 kHz (XPLOD)
High: ±10 dB at 10 kHz (XPLOD)
Power requirements: 12 V DC boat battery
(negative ground (earth))
Dimensions: Approx. 178 × 50 × 180 mm
1
× 2 × 7
(7
/
8
Mounting dimensions: Approx. 182 × 53 × 163 mm
1
× 2
1
(7
/
4
Mass: Approx. 1.0 kg (2 lb 4 oz)
Supplied accessories:
Card remote commander: RM-X151
USB connector for iPod XA-50IP
Parts for installation and connections (1 set)
Design and specifications are subject to change
without notice.
FM/AM DIGITAL MEDIA PLAYER
US Model
1
/
in) (w/h/d)
8
× 6
1
/
/
in) (w/h/d)
8
2

Advertisement

Table of Contents
loading

Related Manuals for Sony DSX-MS60

Summary of Contents for Sony DSX-MS60

  • Page 1: Specifications

    Design and specifications are subject to change Output: Speaker outputs without notice. Speaker impedance: 4 – 8 ohms Maximum power output: 52 W × 4 (at 4 ohms) FM/AM DIGITAL MEDIA PLAYER 9-893-049-01 Sony Corporation 2010L05-1 © 2010.12 Published by Sony Techno Create Corporation...

  • Page 2: Table Of Contents

    (sold DISASSEMBLY separately). Please see your nearest authorized 3-1. Disassembly Flow ............Sony dealer for details on the satellite radio 3-2. Top Cover Block ............. tuner module. 3-3. Tray Assy ................ “SAT Radio,” “SAT Radio Ready,” the SAT Radio and SAT Radio Ready logos and all 3-4.

  • Page 3: Servicing Notes

    DSX-MS60 SECTION 1 SERVICING NOTES UNLEADED SOLDER NOTE FOR REPLACEMENT OF THE AUX JACK (J901) Boards requiring use of unleaded solder are printed with the lead- To replace the AUX jack requires alignment. free mark (LF) indicating the solder contains no lead.

  • Page 4: General

    DSX-MS60 SECTION 2 This section is extracted GENERAL from instruction manual. Satellite radio tuner (XM/SIRIUS) Syntoniseur radio satellite (XM/SIRIUS) Sintonizador de radio por satélite (XM/SIRIUS) FRONT AUDIO OUT REAR / SUB AUDIO OUT from boat antenna (aerial) de l’antenne du bateau...
  • Page 5 You may not be able to install this unit in some makes of driving operations. Tournez le crochet vers Japanese cars. In such a case, consult your Sony dealer. Avoid installing the unit in areas subject to dust, dirt, l’intérieur.

  • Page 6: Disassembly

    DSX-MS60 SECTION 3 DISASSEMBLY • This set can be disassembled in the order shown below. 3-1. DISASSEMBLY FLOW FRONT PANEL SECTION Note: Illustration of disassembly is omitted. 3-2. TOP COVER BLOCK (Page 6) 3-3. TRAY ASSY 3-4. SUB PANEL COMPLETE ASSY...
  • Page 7 DSX-MS60 3-3. TRAY ASSY 4 tray assy 1 screw (P2.6 3 connector (CN201) 1 screw (P2.6 1 two screws (P2.6 3-4. SUB PANEL COMPLETE ASSY 2 two claws 1 two screws (P2.6 2 two claws 4 flexible flat cable (17 core)
  • Page 8 DSX-MS60 3-5. MAIN BOARD 5 connection cord for automobile 1 fuse (blade type) (auto fuse) (10A/32V) (FU701) 4 screw (PTT2.6 3 connector 7 three screws (CN901) (PTT2.6 6 two screws (PTT2.6 qd MAIN board 2 Lift up the lead pin.

  • Page 9: Diagrams

    MUTING CD_WRST /RST CONTROL Q201 CD_ZDET ZDET DEC_SSTBY /SRAMSTB DEC_INT 53 DEC_REQ DEC_XMUTE 56 DEC_XMUTE J601 SONY BUS INTERFACE (BUS CONTROL IN) IC601 D504 DATA IN UNISO DATA I/O DOOR_SW F_AUX DATA OUT 8 UNISI (Page 11) X201 CLK_IN 11...

  • Page 10: Block Diagram - Audio Section (2/2)

    DSX-MS60 4-2. BLOCK DIAGRAM - AUDIO Section (2/2) - (Page 9) R-CH ELECTRICAL VOLUME, INPUT SELECT IC401 MUTING MUTING MUTING Q906 Q904 Q902 (Page 9) AU_LCH CD_LCH OUT_FLCH 34 FRONT R-CH AUDIO OUT OUT_RLCH 32 R-CH REAR/SUB AUDIO OUT R-CH...

  • Page 11: Panel, Power Supply Section

    DSX-MS60 4-3. BLOCK DIAGRAM - PANEL, POWER SUPPLY Section - LIQUID CRYSTAL DISPLAY DRIVER SYSTEM CONTROLLER IC981 IC501 (3/3) LED991, 992 LED DRIVE P1/S1 (LCD BACK LIGHT) Q992 +1.5V B+ SWITCH LED915 - 920 IC201 +1.5V REGULATOR LED DRIVE Q202, 203...
  • Page 12 DSX-MS60 THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. • Waveforms (In addition to this, the necessary note is printed in each block.) – MAIN Board – For Printed Wiring Boards. For Schematic Diagrams. IC501 qd (X_OUT)

  • Page 13: Schematic Diagram - Main Section (1/5)

    DSX-MS60 4-4. SCHEMATIC DIAGRAM - MAIN Section (1/5) - • See page 12 for Waveforms. • See page 23 for IC Block Diagrams. • See page 27 for IC Pin Function Description. MAIN BOARD (1/5) R161 R159 MAIN BOARD USB_GND...

  • Page 14: Schematic Diagram - Main Section (2/5)

    DSX-MS60 4-5. SCHEMATIC DIAGRAM - MAIN Section (2/5) - • See page 23 for IC Block Diagrams. MAIN BOARD (2/5) IC B/D IC301 POWER AMP, REGULATOR IC301 TDF8556AJ/N3 C602 TH601 C601 R605 C301 0.22 C302 0.22 J601 CONTROL IN C312 R602 0.22...

  • Page 15: Schematic Diagram - Main Section (3/5)

    DSX-MS60 4-6. SCHEMATIC DIAGRAM - MAIN Section (3/5) - • See page 23 for IC Block Diagrams. MAIN BOARD (3/5) CN901 BUS_R AUDIO IN BUS_GND C904 BUS_L 100p CHASSIS_GND R/S_L REAR/SUB AUDIO AU_GND R/S_R FRONT_L C902 C901 AU_GND 100p 100p...

  • Page 16: Schematic Diagram - Main Section (4/5)

    DSX-MS60 4-7. SCHEMATIC DIAGRAM - MAIN Section (4/5) - • See page 12 for Waveforms. • See page 23 for IC Block Diagrams. • See page 27 for IC Pin Function Description. MAIN BOARD (4/5) C219 1000p R206 100k R207...

  • Page 17: Schematic Diagram - Main Section (5/5)

    DSX-MS60 4-8. SCHEMATIC DIAGRAM - MAIN Section (5/5) - • See page 23 for IC Block Diagrams. MAIN BOARD (5/5) 470k IC B/D TEF6617T/V1/S470, 518 1000p 1000p 0.01 470k 2.2uH AMRFIN AMSELOUT2 AMRFDEC AMSELOUT1 ANTENNA 0.22 FMIN2 0.01 AMIFAGC1 560uH...

  • Page 18: Main Board (Component Side)

    DSX-MS60 4-9. PRINTED WIRING BOARD - MAIN Board (Component Side) - • : Uses unleaded solder. D202, 203, 502, 505, D601, 602, 604-606, D702-708, 901 MAIN BOARD (COMPONENT SIDE) Q902 Q901 R309 R308 C306 C304 C336 C601 C903 Q905 Q906...

  • Page 19: Main Board (Conductor Side)

    DSX-MS60 4-10. PRINTED WIRING BOARD - MAIN Board (Conductor Side) - • : Uses unleaded solder. (FRONT VIEW) M301 (FAN) J701 MAIN BOARD FU701 REMOTE (CONDUCTOR SIDE) FRONT REAR / SUB CONTROL IN AUDIO IN AUDIO OUT AUDIO OUT (ANTENNA IN) WHT/BLK FRONT Lch (–)

  • Page 20: Printed Wiring Board - Sub Board

    DSX-MS60 4-11. PRINTED WIRING BOARD - SUB Board - 4-12. SCHEMATIC DIAGRAM - SUB Board - • : Uses unleaded solder. SUB BOARD SUB BOARD (Page 21) CN991 (SIDE A) LED_GND KEY BOARD CN901 LCD_GND LED995 +B_LCDLED AUX_L DEVICE INSIDE...

  • Page 21: Printed Wiring Board - Key Board

    DSX-MS60 4-13. PRINTED WIRING BOARD - KEY Board - • : Uses unleaded solder. S952, 955 – 959 S951, 953, 954 LED915 – 920, LED923 – 926 KEY BOARD (COMPONENT SIDE) LED924, S953 LED918 S952 IC982 LED923, S951 PAUSE (UPPER) LED917 + >...

  • Page 22: Schematic Diagram - Key Board

    DSX-MS60 4-14. SCHEMATIC DIAGRAM - KEY Board - KEY BOARD LED991 NESW505CT-AST (LCD BACK LIGHT) R951 R900 R901 S951 LED992 LED923, S951 LED923 NESW505CT-AST CL-197HB1E-D-T SOURCE (LCD BACK LIGHT) R902 R903 R983 R991 R915 R917 R919 R952 IC982 R984 R992...

  • Page 23: Ic Block Diagrams

    DSX-MS60 • IC Block Diagrams – MAIN Board – IC1 TEF6617T/V1/S470, 518 AMRFIN 1 AMOUT2 AMOUT1 AMRFDEC 2 TUNER AMIFAGC1 FMIN2 3 AMSELIN2 TUNER FMIN1 4 AMSELIN1 GNDRF 5 VCC+8.5V 6 TESTCT VCOREF AMRFAGC 7 TUNING VCOLOOP LOUT 8 STEREO DECODER...
  • Page 24 DSX-MS60 IC301 TDF8556AJ/N3 I2C_SIO OUT-FL– C BUS I2C_SCK OUT-FL+ OUT-RL– P-GND1 OUT-RL+ IN-RL IN-FL S-GND PROTECTION/ DIAGNOSTIC IN-FR IN-RR BEEP OUT-RR+ P-GND3 OUT-RR– OUT-FR+ STANDBY/ MUTE OUT-FR– CHIP DETECT/ P-GND4 DIAGNOSTIC TEMPERATURE PROTECTION DIAG ENABLE LOGIC SWITCH ANT-REM CRES AMP-REM...
  • Page 25 DSX-MS60 IC401 BD3447AFV-E2 I2C BUS LOGIC, FADER FADER FADER FADER FADER EFFECT 180 /0 7 BAND 3 BAND P-EQ (TONE CONTROL) SPECTRUM ANALYZER /LEVEL METER VOLUME/MUTE SPEANA LVL METER SPEANA LVL METER INPUT GAIN INPUT SELECTOR (3 SIGLE-END AND 3 STEREO IS O)
  • Page 26 DSX-MS60 IC601 BA8271F-E2 RESET SWITCH IC801 BD9070FP-E2 PVIN PVIN N.C. – N.C. VREGB 1 – – VIN 2 LOGIC – N.C. 3 SLOPE N.C. 4 PGND 5 UVLO, TSD, SOFT GND 6 OVP, OCP, SCP START – RT 7 SYNC...
  • Page 27 DSX-MS60 • IC Pin Function Description MAIN BOARD IC201 TC94A92FG-301 (M) (DIGITAL SIGNAL PROCESSOR) Pin No. Pin Name Description VCOI DSP VCO control voltage input terminal RVDD3 Power supply terminal (+3.3V) SLCO EFM slice level output terminal Not used RF signal input terminal...
  • Page 28 DSX-MS60 Pin No. Pin Name Description Bit clock signal input from the USB controller LRCK L/R sampling clock signal (44.1 kHz) input terminal for audio data input ZDET Zero detection signal output terminal VDD3 Power supply terminal (+3.3V) 62, 63...
  • Page 29 DSX-MS60 MAIN BOARD IC204 92FD28AFG7F88 (SYJZ) (USB CONTROLLER) Pin No. Pin Name Description RESET Reset signal input from the system controller “L”: reset BU_IN Back up power supply detection signal input terminal “H”: back up power on Detection input terminal from the disc self store detect switch on the mechanism deck section MEC_SELFSW Fixed at “H”...
  • Page 30 DSX-MS60 Pin No. Pin Name Description BOOT Boot mode selection signal input terminal “L”: boot mode 70, 71 Not used Function mode selection signal input terminal Fixed at “H” in this set System clock output terminal (9 MHz) DVSS Ground terminal...
  • Page 31 TEL_ATT At input of “H”, the audio signal is attenuated by 20 dB Muting on/off control signal output terminal BUS_ON SONY bus on/off control signal output to the SONY bus interface “L”: bus on SYS_RST Reset signal output terminal CD_ON...
  • Page 32 DSX-MS60 Pin No. Pin Name Description Power supply terminal (+3.3V) Ground terminal Not used AMP_STB Standby control signal output to the power amplifi er DIAG Diagnostic signal input from the power amplifi er EJECT_OK Eject OK signal output terminal SA_OUT...

  • Page 33: Exploded Views

    DSX-MS60 SECTION 5 EXPLODED VIEWS Note: • -XX and -X mean standardized parts, so • Color Indication of Appearance Parts Ex- they may have some difference from the ample: original one. KNOB, BALANCE (WHITE) . . . (RED) ↑ ↑...

  • Page 34: Front Panel Section

    DSX-MS60 5-2. FRONT PANEL SECTION not supplied (KEY board) RE901 not supplied not supplied not supplied not supplied J901 LCD901 not supplied not supplied not supplied not supplied Note: Refer to the servicing notes “NOTE FOR REPLACEMENT OF THE AUX JACK (J901)” (See page 3), if replacing the Ref. No. J901.

  • Page 35: Electrical Parts List

    DSX-MS60 SECTION 6 ELECTRICAL PARTS LIST Note: • Due to standardization, replacements in • CAPACITORS When indicating parts by reference num- the parts list may be different from the uF: μF ber, please include the board name. parts specifi ed in the diagrams or the com- •...
  • Page 36 DSX-MS60 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R951 1-216-820-11 METAL CHIP 1/10W 1-162-970-11 CERAMIC CHIP 0.01uF R952 1-216-821-11 METAL CHIP 1/10W 1-165-908-11 CERAMIC CHIP 1uF R953 1-216-821-11 METAL CHIP 1/10W 1-162-970-11 CERAMIC CHIP 0.01uF...
  • Page 37 DSX-MS60 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C271 1-162-914-11 CERAMIC CHIP 9PF 0.5PF C601 1-107-826-11 CERAMIC CHIP 0.1uF C301 1-115-340-11 CERAMIC CHIP 0.22uF C602 1-126-941-11 ELECT 470uF C302 1-115-340-11 CERAMIC CHIP 0.22uF C603 1-162-970-11 CERAMIC CHIP 0.01uF...
  • Page 38 DSX-MS60 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < DIODE/VARISTOR > IC205 6-713-126-01 IC MFI341S2159 IC301 6-715-848-11 IC TDF8556AJ/N3 D201 6-501-656-01 DIODE LBAT54ALT1G IC302 6-702-302-01 IC TK11133CSCL-G D202 6-502-961-01 DIODE DA2J10100L IC303 6-712-776-01 IC PST8228UL...
  • Page 39 DSX-MS60 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark Q907 8-729-038-30 TRANSISTOR RT1P141M-TP-1 Q908 8-729-038-37 TRANSISTOR RT1N141M-TP-1 R231 1-414-385-21 INDUCTOR, FERRITE BEAD Q909 8-729-029-06 TRANSISTOR DTC124EUA-T106 R232 1-216-821-11 METAL CHIP 1/10W Q910 8-729-028-83 TRANSISTOR DTA124EUA-T106...
  • Page 40 DSX-MS60 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R306 1-216-295-00 SHORT CHIP R557 1-216-845-11 METAL CHIP 100K 1/10W R307 1-216-845-11 METAL CHIP 100K 1/10W R558 1-216-829-11 METAL CHIP 4.7K 1/10W R308 1-216-813-11 METAL CHIP...
  • Page 41 DSX-MS60 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark ACCESSORIES R913 1-216-009-00 METAL CHIP 1/10W ************ R914 1-216-817-11 METAL CHIP 1/10W R915 1-216-817-11 METAL CHIP 1/10W 1-479-077-17 REMOTE COMMANDER (RM-X151) R916 1-216-834-11 METAL CHIP 1/10W...
  • Page 42 DSX-MS60 REVISION HISTORY Checking the version allows you to jump to the revised page. Also, clicking the version at the top of the revised page allows you to jump to the next revised page. Ver. Date Description of Revision 2010.12...

Table of Contents