Table of Contents
Advertisement
Quick Links
Owner's Manual
Instructions for Assembly and Operation
Broadcast Kit:
READ and UNDERSTAND the Owner's Manual completely before using this sprayer.
Assemble, test, and use only in accordance with the Owner's Manual instructions.
READ and FOLLOW chemical label instructions. Pesticides are hazardous chemicals.
KNOW emergency procedures BEFORE handling chemicals. Sprayer leaks, bodily
chemical contact, poisoning, and spills require immediate response.
AVOID inhaling, ingesting, or coming into contact with any chemicals.
WEAR personal protective gear when filling, using, cleaning, and servicing the
sprayer.
KEEP sprayer and spray materials away from children and pets. Pesticides are
especially toxic to them.
EXERCISE CAUTION in vehicle handling when towing/hauling a filled sprayer to
avoid loss of control or sprayer overturning.
DO NOT TURN ON POWER to sprayer until ready to spray in order to avoid unintentional
spray release.
Improper use of the sprayer or handling of chemicals could result in serious injury or
illness to the operator or nearby persons/animals, or could cause damage to the
environment.
** This sprayer is recommended for use in spraying non-flammable liquids such as pesticides, water for
plants/trees or dust control, ice control chemicals, or water-based non-flammable sealants or stains for
outdoor wood surfaces. However, WE RECOMMEND THAT THE SPRAYER NOT BE USED FOR
OTHER PURPOSES ONCE IT HAS BEEN USED FOR SPRAYING PESTICIDES. Any chemical will
leave some residual in the tank liner or sprayer components, even after the sprayer has been properly
cleaned. These residual chemicals can have unexpected effects on future uses. For example, spraying
water or other liquids that are contaminated with residual pesticide may result in unforeseen hazards to
plant or animal life.
Any Questions, Comments, Problems, or Parts Orders
For outdoor use with agricultural
pesticides and other liquids**
WARNING
Contact your vendor.
1
M803994
ITEM NUMBER: DSNBK
SERIAL NUMBER:
Advertisement
Table of Contents
Related Manuals for Daken M803994
Summary of Contents for Daken M803994
- Page 1 M803994 ITEM NUMBER: DSNBK SERIAL NUMBER: Owner’s Manual Instructions for Assembly and Operation For outdoor use with agricultural Broadcast Kit: pesticides and other liquids** WARNING READ and UNDERSTAND the Owner’s Manual completely before using this sprayer. Assemble, test, and use only in accordance with the Owner’s Manual instructions.
-
Page 2: Hazard Signal Word Definitions
Hazard Signal Word Definitions... -
Page 3: Summary Of Important Safety Information
Summary of Important Safety Information WARNING Read and understand this owner’s manual completely before using the sprayer. Read each chemical label’s instructions before handling the chemical. Improper use of the sprayer or handling of chemicals could result in serious injury or illness for the operator or nearby persons/animals, or cause damage to the environment. - Page 4 Summary of Important Safety Information (continued) During Spraying • DO NOT OVERAPPLY pesticide. Apply at rate recommended by chemical manufacturer. Excess pesticide can be dangerous to humans/animals, damage desirable plants, and contaminate soil and water sources. • DO NOT EAT, DRINK, SMOKE, RUB YOUR EYES, or TOUCH YOUR BARE SKIN while handling chemicals and spraying.
- Page 5 Assembly Step One: Unpack and inspect parts Broadcast Lance p/n 788410 24” Hose M5-0.8 x 14mm 10-24 x 1/2” p/n 798619 Phillips Screw (2) Phillips Screw (2) Fine Thread Coarse Thread p/n 82600 p/n 82059 Broadcast Fitting Broadcast Bracket Hose Clamp (2) Broadcast Nozzle p/n 779854 p/n 30746...
- Page 6 Assembly (continued) Step Three: Finish broadcast kit assembly 1. Remove hex plug from pump outlet. Remove the hex plug 2. Push broadcast lance into broadcast bracket. Note orientation. 3. Install hose barb into open port on pump. Hand tighten, then one turn with a wrench. 4.
-
Page 7: Operation
Operation Step One: Operate the broadcast kit Note: See sprayer owner’s manual for sprayer operating instructions WARNING ALWAYS wear personal protective equipment as directed on the chemical label when spraying. Long pants and sleeves, chemical-resistant gloves, and eye protection are strongly recommended. - Page 8 Operation 6. Squeeze trigger & To spray, squeeze the gun trigger. adjust nozzle - Twist the spray nozzle to adjust from a straight stream to hollow cone spray pattern, as recommended on the chemical label for proper delivery rate. Note: It is not unusual for the operator to be exposed to chemical drips while adjusting the nozzle –...
- Page 9 Operation A. Move broadcast lance into the broadcast position 7. Operate Ensure power to the pump is off, then lift the broadcast lance out of its broadcast spraying system stored position and click the lance into its broadcast position. Stored position Broadcast position B.
- Page 10 Operation C. Ensure correct spray pattern Rotate the broadcast nozzle, if needed, so that the spray pattern is pointed down and evenly distributed. Note: It is not unusual for the operator to be exposed to chemical drips while adjusting the broadcast nozzle. Wear chemical resistant gloves.
- Page 11 Operation NOTE!! Broadcast lance and spot spray gun can be used simultaneously. Use the spot spray gun if you desire to apply pesticide only on selected plants. Use the broadcast nozzle if you wish to spray large ground areas. If the sprayer must be left unattended at any time: 7.
- Page 12 Operation Step Two: Clean sprayer and decontaminate after use. When done using the sprayer, it is important to clean the sprayer and decontaminate yourself. Do not store the sprayer with chemicals in the tank, as it is unsafe and could also result in damage to the equipment.
-
Page 13: Appendix A - Broadcast Spray Calibration Tables
Appendix A – Broadcast Spray Calibration Tables Below are some guidelines to help you calibrate your broadcast sprayer. This is a very important step in operating the broadcast sprayer such that too much or too little chemical may be applied. Using Table 1, find a table that corresponds with the chemical manufacturer’s suggested application rate (litres per hectare, litres per 100 sq.m or litres per 10 sq.m). -
Page 14: Limited Warranty
Please fill in the following information and have it on hand when you call in a warranty claim. Customer Number: Date of Purchase: Daken Serial Number: Item Number:... - Page 15 This page was intentionally left blank.
- Page 16 Sales & Product Enquiries: Call us on (Toll Free) 1800 648 384, or email sales@clarkfarmequipment.com.au Operating 8:30am - 5pm Monday to Friday Product & Technical Support: Call us on (Toll Free) 1800 817 366, or email support@clarkfarmequipment.com.au Operating 8:30am - 5pm Monday to Friday (Limited hours on weekends) Imported By: Big Box Products PTY LTD...