Page 1: Ir Blaster G-Link Jack
ORDER NO.MTNC060802CE B19 Canada: B07 Digital High Definition Plasma Television TH-65PX600U GP9DU Chassis Specifications Power Source AC 120 V, 50/60 Hz Power Consumption Maximum 795 W Standby condition 0.2 W (With CableCARD : 22 W) Plasma Display panel Drive method...
Page 2: Table Of Contents
TH-65PX600U AUDIO L-R: Stereo Mini Jack ( 3.5 mm) × 1 IR Blaster G-LINK Jack × 1 Card slot SD CARD slot × 1, CableCARD slot × 1 AV PROG. OUT VIDEO: RCA PIN Type × 1 1.0 V [p-p] (75 ohm) AUDIO L-R: RCA PIN Type ×...
Page 3 TH-65PX600U 9.4. No Picture 15.15. G, GK, K, R and S-Board Block Diagram 9.5. Local screen failure 15.16. G, GK, K, R and S-Board Schematic Diagram 10 Serviceman Mode 15.17. DG-Board (1 of 4) and GH-Board Block Diagram 10.1. How to enter into Serviceman Mode 15.18.
Page 4 TH-65PX600U 15.69. SC-Board (1 of 4) Schematic Diagram 15.81. SS-Board (1 of 2) Schematic Diagram 15.70. SC-Board (2 of 4) Schematic Diagram 15.82. SS-Board (2 of 2), SS2 and SS3-Board Schematic 15.71. SC-Board (3 of 4) Schematic Diagram Diagram 15.72. SC-Board (4 of 4) Schematic Diagram 16 Parts Location &...
Page 5: Applicable Signals
TH-65PX600U 1 Applicable signals...
Page 6: Safety Precautions
TH-65PX600U 2 Safety Precautions 2.1. General Guidelines 1. When servicing, observe the original lead dress. If a short circuit is found, replace all parts which have been overheated or damaged by the short circuit. 2. After servicing, see to it that all the protective devices such as insulation barriers, insulation papers shields are properly installed.
Page 7: Prevention Of Electro Static Discharge (Esd) To
TH-65PX600U 3 Prevention of Electro Static Discharge (ESD) to Electrostatically Sensitive (ES) Devices Some semiconductor (solid state) devices can be damaged easily by static electricity. Such components commonly are called Electrostatically Sensitive (ES) Devices. Examples of typical ES devices are integrated circuits and some field-effect transistors and semiconductor "chip"...
Page 8: About Lead Free Solder (Pbf)
TH-65PX600U 4 About lead free solder (PbF) Note: Lead is listed as (Pb) in the periodic table of elements. In the information below, Pb will refer to Lead solder, and PbF will refer to Lead Free Solder. The Lead Free Solder used in our manufacturing process and discussed below is (Sn+Ag+Cu).
Page 9: Service Hint
TH-65PX600U 5 Service Hint Board Name Function Board Name Function Power Supply Data Driver (Upper Right) DC-DC Converter Data Driver (Upper Center) Speaker out, Audio AMP, Fan Control Data Driver (Upper Left) AV Terminal, AV Switch Data Driver (Lower Left)
Page 10: Plasma Panel Replacement Method
TH-65PX600U 6 Plasma panel replacement method 6.1. Remove the Back cover 6.4. Remove the P(P-2)-Board 1. See Service Hint (Section 5) Caution: 6.2. Remove the rear terminal To remove P.C.B. wait 1 minute after power was off for discharge from electrolysis capacitors.
Page 11: Remove The Pa-Board
TH-65PX600U 6.5. Remove the PA-Board 2. Disconnect the couplers (D3, D5, DT10, H51, PA2, PA40 and relay couplers). 1. Unlock the cable clampers to free the cable. 3. Disconnect the flexible cables (DG11 and PA20). 2. Disconnect the couplers (PA2, PA5, PA10, PA31, PA32, 4.
Page 12: Remove The Dg-Board
TH-65PX600U 6.9. Remove the DG-Board 1. Remove the DT-Board unit. (See section 6.8.) 2. Remove the screws (×8 ) and remove the DT-Board metal frame. 6. Release the DT-Board shield case body claws (×6 7. Remove the DT-Board. 3. Disconnect the couplers (DG2, DG3 and DG5).
Page 13: Remove The H-Board
TH-65PX600U 6.10. Remove the H-Board 6.12. Remove the Fan (Big and Middle/L) 1. Unlock the cable clampers to free the cable. 2. Disconnect the couplers (H2, H40 and H51). 1. Disconnect the relay coupers. 3. Disconnect the flexible cable (H1).
Page 14: Remove The Fan (Ss)
TH-65PX600U 6.14. Remove the Fan (SS) 6.16. Remove the Shield cover (B) and (C) 1. Disconnect the relay coupers. 2. Remove the screws (×4 ) and remove the Fan unit (SS). 1. Remove the screws (×2 each). 3. Remove the screws (×4 ) and remove the Fan (SS).
Page 15: Remove The Esc-Fixing Metal (A)
TH-65PX600U 6.18. Remove the Esc-fixing metal 1. Remove the screws (×4 each). 2. Remove the Esc-fixing metal (A). 6.21. Remove the SD-Board 1. Remove the screws (×4 6.19. Remove the Esc-fixing metal 2. Remove the flexible cables (SD1, SD2, SD3, SD4 and SD5) connected to the SD-Board and remove the bridge connector (SD46).
Page 16: Remove The Sc-Board
TH-65PX600U 6.22. Remove the SC-Board 6.24. Remove the SS3-Board 1. Unlock the cable clampers to free the cable. 1. Unlock the cable clampers to free the cable. 2. Remove the Fan (SC). (See section 6.13.) 2. Disconnect the coupler (SS27) and disconnect the flexible cables (SS57 and SS58).
Page 17: Remove The Reinforcement Angles (L, R) And The
TH-65PX600U 6.26. Remove the Reinforcement 6.28. Remove the C2-Board Angles (L, R) and the 1. Remove the Fan unit (Big and Middle/L). (See section Connection Plate (A, B, C, D) 6.12.) 2. Remove the Esc-fixing metal (B). (See section 6.19.) 1.
Page 18: Remove The C4-Board
TH-65PX600U 6.30. Remove the C4-Board 6.32. Remove the C6-Board 1. Remove the Speaker Terminal unit (L). (See section 6.17.) 1. Remove the Speaker Terminal unit (R). (See section 6.17.) 2. Remove the Esc-fixing metal (A) and (B). (See section 6.18.
Page 19: Remove The G-Board, Gh-Board And Gk-Board
TH-65PX600U 6.34. Remove the G-Board, GH- Board and GK-Board 1. Remove the front bracket. (See section 6.33.) 2. Remove the screws (×3 ) and remove the front bracket cover. 6.35. Remove the GS-Board 1. Remove the Shield cover (B). (See section 6.16.) 3.
Page 20: Remove The K-Board, R-Board And The S-Board
TH-65PX600U 6.36. Remove the K-Board, R-Board and the S-Board 1. Unlock the cable clampers to free the cable. 2. Disconnect the couplers (G1 and G4). (See section 6.33.) 3. Remove the screws (×6 ) and remove the L/Front Panel- left-assembly.
Page 21: Replace The Plasma Panel (Finished)
TH-65PX600U 4. For leaving the plasma panel from the front frame, pull the bottom of the front frame forward, lift, and remove. 6.38. Replace the plasma panel (finished) 1. Place the new plasma panel (finished) on the flat surface of the table (covered by a soft cloth), with the plasma panel surface facing downward.
Page 22: Caution Statement
TH-65PX600U 7 Caution statement 7.1. Caution statement. Caution: Please confirm that all flexible cables are assembled correctly. Also make sure that they are locked in the connectors. Verify by giving the flexible cables a very slight pull.
Page 23: Location Of Lead Wiring
TH-65PX600U 8 Location of Lead Wiring 8.1. Lead of Wiring (1)
Page 24: Lead Of Wiring
TH-65PX600U 8.2. Lead of Wiring (2)
Page 25: Lead Of Wiring
TH-65PX600U 8.3. Lead of Wiring (3)
Page 26 TH-65PX600U 8.4. Lead of Wiring (4)
Page 27 TH-65PX600U 8.5. Lead of Wiring (5)
Page 28: Self-Check Function
TH-65PX600U 9 Self-check Function Use the self-check function to test the unit. 1. Checking the IIC bus lines 2. Power LED Blinking timing 9.1. Check of the IIC bus lines 9.1.1. How to access Produce TV reception screen, and while pressing [VOLUME ( - )] button on the main unit, press [OK] button on the remote control for more than 3 seconds.
Page 29 TH-65PX600U 9.1.4. Check Point Confirm the following parts if NG was displayed. Display Ref.No. Description Board TU8200 TV Tuner DT-Board IC8211 Front Processor DT-Board IC8013 HDMsL PEAKS_Lite DT-Board IC2304 Digital Sound Processor PA-Board IC2300 PWM Processor PA-Board AVSWV IC2601 Video SW...
Page 30: Power Led Blinking Timing Chart
TH-65PX600U 9.2. Power LED Blinking timing chart 1. Subject Information of LED Flashing timing chart. 2. Contents When an abnormality has occurred the unit, the protection circuit operates and reset to the stand by mode. At this time, the defective block can be identified by the number of blinkes of the Power LED on the front panel of the unit.
Page 31: No Power
TH-65PX600U 9.3. No Power First check point There are following 2 states of No Power indication by power LED. 1. No lit 2. Red is lit then turns red blinking a few seconds later. (See 9.2.)
Page 32: No Picture
TH-65PX600U 9.4. No Picture...
Page 33: Local Screen Failure
TH-65PX600U 9.5. Local screen failure Plasma display may have local area failure on the screen. Fig-1 is the possible defect P.C.B. for each local area. Fig-1...
Page 34: Serviceman Mode
TH-65PX600U 10 Serviceman Mode 10.1. How to enter into Serviceman Mode While pressing [VOLUME ( - )] button of the main unit, press [RECALL] button of the remote control three times within 3 seconds. 10.1.1. Key command “1” button...Main items Selection in forward direction “2”...
Page 35: Memory Edit Mode
TH-65PX600U 10.3. Memory edit mode 10.3.1. How to access 1. Select “OPTION” in Service man Mode. 2. Press [MUTE] button on the remote control for more than 3 seconds. 10.3.2. Exit 1. Press [1] button on the remote control.
Page 36: Device Data Mode
TH-65PX600U 10.4. Device data mode Device data display obtain IIC lead status and various processing values for the problem analysis by the market etc. 10.4.1. How to access 1. Select the memory edit mode. 2. Press [RECALL] button on the remote control.
Page 37: Adjustment Procedure
TH-65PX600U 11 Adjustment Procedure 11.1. Driver Set-up 11.1.2. Adjustments Adjust driver section voltages referring the panel data on the 11.1.1. Item / Preparation panel data label. 1. Input a white signal to plasma video input. Check or adjust the following voltages with the multimeter.
Page 38: Initialization Pulse Adjust
TH-65PX600U 11.2. Initialization Pulse Adjust 1. Input the White signal to plasma video input. 2. Set the picture controls as follows. Picture menu : Vivid Normal : Set Aspect : Full 3. Connect Oscilloscope to TPSC1 (SC). Check that the flat section is less than 40µ Sec and adjust VR6602 for 160+10µ Sec.
Page 39: Adjustment Volume Location
TH-65PX600U 11.4. Adjustment Volume Location 11.5. Test Point Location...
Page 40: Adjustment
TH-65PX600U 12 Adjustment 12.1. White balance adjustment Instrument Name Connection Remarks · W/B pattern Component input User setting: Normal Panel surface · Color analyzer (Minolta CA-100 or equivalent) Procedure Remarks · Ensure aging is adequate. Pic Menu: Vivid Picture: +30 ·...
Page 41 TH-65PX600U...
Page 42: Sub Bright Adjustment
TH-65PX600U 12.2. Sub bright adjustment Instrument Name Connection Remarks 1. NTSC signal generator The input terminal Picture menu: Vivid Color temp: Cool ASPECT: Full Procedure Remarks · Color balance adjustment is finished for each signal. TV is set to 0IRE when it is in factory mode.
Page 43: Abl Operation Level Adjustment
Adjust to shift large to small for DAC. 1. It is OK that falling down the power few watts when exiting the factory adjustment mode. 2. Adjust the large number for DAC when they have 2 adjustment points. Factory adjustment with OSD TH-65PX600U 695 ± 8W...
Page 44: Hotel Mode
TH-65PX600U 13 Hotel mode 1. Purpose item Function Mode Select hotel mode ON/OFF Restrict a function for hotels. Input Select input signal modes. 2. Access command to the Hotel mode setup menu Set the input, when each time power is switched on.
Page 45: Conductor Views
TH-65PX600U 14 Conductor Views 14.1. P-Board P(P-1)-BOARD (FOIL SIDE) ETXMM631MGHS (NPX631MB-1) TH-65PX600U TH-65PX600U P-BOARD ETXMM631MGHS P-BOARD ETXMM631MGHS...
Page 46 TH-65PX600U Parts Location Parts Location P(P-1)-BOARD (FOIL SIDE) P(P-1)-BOARD (COMPONENT SIDE) TRANSISTOR PHOTO COUPLER VOLUME Q301 IC401 PC505 VR351 IC401 Q302 IC501 PC506 VR401 IC501 Q303 PC507 Q304 MODULE MODULE Q351 TRANSISTOR MC301 Q352 MC301 Q301 MC401 Q353 MC401 Q302...
Page 47 TH-65PX600U P(P-1)-BOARD (COMPONENT SIDE) ETXMM631MGHS (NPX631MB-1) TH-65PX600U TH-65PX600U P-BOARD ETXMM631MGHS P-BOARD ETXMM631MGHS...
Page 48 TH-65PX600U P(P-2)-BOARD (FOIL SIDE) ETXMM631MGHS (NPX631MB-2) TH-65PX600U TH-65PX600U P-BOARD ETXMM631MGHS P-BOARD ETXMM631MGHS...
Page 49 TH-65PX600U Parts Location Parts Location P(P-2)-BOARD (FOIL SIDE) P(P-2)-BOARD (COMPONENT SIDE) MODULE TRANSISTOR MODULE TRANSISTOR Q201 Q201 MC201 MC201 Q202 Q202 MC202 MC202 Q203 Q203 MC1601 MC1601 Q204 Q204 Q205 Q1602 PHOTO COUPLER PHOTO COUPLER Q206 Q1603 Q251 Q1606 PC201...
Page 50 TH-65PX600U P(P-2)-BOARD (COMPONENT SIDE) ETXMM631MGHS (NPX631MB-2) TH-65PX600U TH-65PX600U P-BOARD ETXMM631MGHS P-BOARD ETXMM631MGHS...
Page 51: Pa-Board
TH-65PX600U 14.2. PA-Board PA-BOARD (FOIL SIDE) TXNPA1DRTU C5839 JS2323 L5803 L5804 C5803 JS2302 C5843 C5844 C5837 D5803 R5809 R5845 R5805 L2308 C5821 D5817 R5807 C5841 L5802 R2391 R5834 C5809 C2353 R5833 R2392 R5822 R5839 R5840 C2332 C5845 R5803 C5840 C2333...
Page 52 TH-65PX600U PA-BOARD (COMPONENT SIDE) TXNPA1DRTU PA50 L5803 L5804 PA31 PA10 C5838 JS2303 D5804 D5830 C5811 D5828 R5815 D5825 C5817 D5826 JS2325 C5822 L2308 R5836 C5813 C5823 R5837 D5831 D5827 C2333 D5829 C5841 PAMM3 IC5802 C5845 D5838 L2301 PA35 C5818 R5838...
Page 53: H-Board
TH-65PX600U 14.3. H-Board H-BOARD (FOIL SIDE) TZRNA03DRTU C2741 C2743 C2730 C2734 TNPA4067 C2717 REVERSE FOR SUFFIX. C2715 R2806 C2782 R2771 C2708 R2773 C2710 C2602 Parts Location C2750 H-BOARD (FOIL SIDE) C2624 C2791 TP9V TP30V C2670 C2672 HMM5 JS2609 JS2714 C2665...
Page 54 TH-65PX600U H-BOARD (COMPONENT SIDE) TZRNA03DRTU JK2604 R2647 HMM3 R2645 C2731 L2609 C2758 R2752 JK2602 JS2633 C2655 L2602 C2767 R2871 R2894 JS2661 C2728 R2786 Parts Location R2646 D2635 D2629 D2636 R2663 R2796 D2662 R2662 D2630 R2787 R2740 H-BOARD (COMPONENT SIDE) R2704...
Page 55: G-Board
TH-65PX600U 14.4. G-Board G-BOARD (FOIL SIDE) G-BOARD (COMPONENT SIDE) TXN/G1DRTU TXN/G1DRTU R3733 JS3704 TNPA4068 REVERSE FOR SUFFIX. C3713 TNPA4068 D3712 R3704 SUFFIX. R3701 R3702 C3717 C3718 C3719 L3703 L3701 L3700 R3708 R3706 R3705 R3728 FL3712 FL3711 FL3710 R3730 JS3705 JS3707...
Page 56: Gh And Gs-Board
TH-65PX600U 14.5. GH and GS-Board GH-BOARD (FOIL SIDE) GH-BOARD (COMPONENT SIDE) TXNGH1DRTU TXNGH1DRTU D808 C802 TP802 R821 D807 L803 GH10 Q801 Q804 L802 R823 R807 D814 IC803 D810 D809 D805 D803 D801 D813 D806 D804 D802 TP804 C823 R811 R806...
Page 57: Gk, H3, K, R And S-Board
TH-65PX600U 14.6. GK, H3, K, R and S-Board K-BOARD (FOIL SIDE) TXN/K1DRTU IC511 IC512 CR No.2 TNPA4073 D535 D511 D532 SEE REVERSE D528 C524 ORDER R567 D531 C511 D533 C522 C520 H3-BOARD TXAUW03DRTU K-BOARD (COMPONENT SIDE) TNPA3003 TXN/K1DRTU SEE REVERSE FOR ORDERNO.
Page 58: Dg-Board
TH-65PX600U 14.7. DG-Board DG-BOARD (FOIL SIDE) TZRNA02DRTU IC1906 TP1906 Q1141 Q1133 Q1140 Q1135 IC1107 CR NO.4 TNPA4043 REVERSE FOR SUFFIX. Q919 Q1142 TP1115 Q1143 IC1503 TP1116 TP1118 TP1119 TP1102 TP1103 TP1104 TP1113 TP1117 Q1128 IC029 Q1136 Q045 TP041 Q083 Q1907...
Page 59 TH-65PX600U Parts Location Parts Location DG-BOARD (FOIL SIDE) DG-BOARD (COMPONENT SIDE) TRANSISTOR TRANSISTOR IC1101 Q1103 TP1101 IC1103 Q1100 TP1108 IC1102 Q1104 TP1102 IC1104 Q1101 TP1109 IC1107 Q1105 IC1105 Q1102 TP1103 TP1110 IC1111 Q1126 TP1104 IC1106 Q1106 TP4042 IC1503 Q1127 TP1105...
Page 60 TH-65PX600U DG-BOARD (COMPONENT SIDE) TZRNA02DRTU IC1907 DG51 IC1602 DG41 Q1109 IC1105 Q1106 Q1107 IC1110 Q1130 Q1131 IC1501 IC020 Q1601 Q1100 IC014 IC1103 Q1101 HC01 Q052 Q054 IC037 IC038 Q1115 Q1125 Q046 Q1116 Q060 Q041 Q042 Q040 Q1114 Q1112 IC027 HC06...
Page 61: Dt-Board
TH-65PX600U 14.8. DT-Board DT-BOARD (FOIL SIDE) TNAG171S L209 L303 IC206 R462 C413 C495 L211 R601 R463 C414 R599 R837 L304 C476 C434 C300 R282 C343 C375 C222 C301 L279 R210 R838 C497 C640 C069 THERMAL PAD R636 C641 IC211 R634...
Page 62 TH-65PX600U DT-BOARD (COMPONENT SIDE) TNAG171S C645 R843 C331 C517 R110 C232 R109 R631 R633 D208 C512 R596 Q228 R108 R299 R107 L107 C513 R598 R302 R106 C627 L105 R597 R105 C626 R104 C511 R111 C337 DT02 Q025 FL264 R100 C336...
Page 63: D-Board
TH-65PX600U 14.9. D-Board D-BOARD (FOIL SIDE) TZTNP01DRTU C856 C857 C863 R452 D301 Q805 R872 Q806 Q301 R871 TNPA3983 R868 R870 REVERSE FOR ORDER CR NO.9 R869 R528 R617 FL806 L505 R560 L504 R636 R530 R646 R873 R647 R120 R875 C859...
Page 64 TH-65PX600U D-BOARD (COMPONENT SIDE) TZTNP01DRTU FL309 FL307 FL308 D302 D300 R454 R394 R396 R393 R395 R440 R397 R461 R441 R462 R453 R455 R457 R458 R400 R409 Q300 R456 TP062 TP061 TNPA3983 R410 IC504 Q302 TP059 TP060 R615 R534 ORDER R612...
Page 65: C1-Board
TH-65PX600U 14.10. C1-Board Parts Location C1-BOARD IC7101 IC7102 IC7103 IC7104 IC7105 IC7106 C1-BOARD (FOIL SIDE) TXNC11EVTJ TNPA4003 SEE REVERSE FOR ORDER NO. C1-BOARD (COMPONENT SIDE) TXNC11EVTJ ZA106 R111 R114 R109 R112 C142 R125 R131 R128 R132 R136 R139 C175 R108...
Page 66: C2-Board
TH-65PX600U 14.11. C2-Board Parts Location C2-BOARD IC7201 IC7202 IC7203 IC7204 IC7205 IC7206 IC7207 IC7211 IC7212 IC7213 IC7214 IC7215 C2-BOARD (FOIL SIDE) TXNC21EVTJ TNPA4004 1 2 3 SEE REVERSE FOR ORDER N O. C2-BOARD (COMPONENT SIDE) TXNC21EVTJ R237 R242 R249 R253...
Page 67: C3-Board
TH-65PX600U 14.12. C3-Board Parts Location C3-BOARD IC7301 IC7302 IC7303 IC7304 IC7305 IC7306 C3-BOARD (FOIL SIDE) TXNC31EVTJ 1 C3 TNPA4005 SEE R EVERSE FOR ORDER NO. C3-BOARD (COMPONENT SIDE) TXNC31EVTJ CA11 CA14 CA12 CA15 R361 R363 CA13 R375 R379 ZA305 ZA304...
Page 68: C4-Board
TH-65PX600U 14.13. C4-Board Parts Location C4-BOARD IC7401 IC7402 IC7403 IC7404 IC7405 IC7406 C4-BOARD (FOIL SIDE) TXNC41EVTJ 1 2 3 TNPA4006 SEE REVERSE FOR ORDER NO. C4-BOARD (COMPONENT SIDE) TXNC41EVTJ ZA402 ZA405 ZA403 C4MM1 C479 TNPA4006 1 C4 C412 C408 C4MM2...
Page 69: C5-Board
TH-65PX600U 14.14. C5-Board Parts Location C5-BOARD IC7501 IC7502 IC7503 IC7504 IC7505 IC7507 IC7511 IC7512 IC7513 IC7514 IC7215 IC7516 C5-BOARD (FOIL SIDE) TXNC51EVTJ TNPA4007 SEE R EVERSE FOR O RDER NO. C5-BOARD (COMPONENT SIDE) TXNC51EVTJ C566 C567 R543 R598 FL503 R599...
Page 70: C6-Board
TH-65PX600U 14.15. C6-Board Parts Location C6-BOARD IC7601 IC7602 IC7603 IC7604 IC7605 IC7606 C6-BOARD (FOIL SIDE) TXNC61EVTJ TNPA4008 SEE R EVERSE FOR O RDER NO. C6-BOARD (COMPONENT SIDE) TXNC61EVTJ C6MM1 C6MM2 ZA604 ZA606 CR NO.7 R641 R659 R655 R639 IC603 IC604...
Page 71: Sc-Board
TH-65PX600U 14.16. SC-Board SC-BOARD (FOIL SIDE) TXNSC1EVTJ TP48 TP42 TP40 TP50 TP46 TP30 TP28 TP29 TP43 TP063 TP042 TP41 TP49 TP47 C693 SC45 SC46 C691 SC41 SC42 SC43 SC44 C460 C440 L680 C806 C809 C808 C692 VR602 VR601 C430 C429...
Page 72 TH-65PX600U Parts Location Parts Location SC-BOARD (FOIL SIDE) SC-BOARD (COMPONENT SIDE) TP23 PHOTO COUPLER Q6501 Q6648 TP24 Q6502 Q6649 IC6471 PC6480 TP15V IC6791 TP036 TP25 Q6503 Q6651 IC6472 PC6610 IC6803 TP037 TPSC1 TP26 Q6504 Q6652 IC6501 PC6701 TP042 TPSOS6 TRANSISTOR...
Page 73 TH-65PX600U SC-BOARD (COMPONENT SIDE) TXNSC1EVTJ ZA401 ZA402 ZA403 C693 C691 SC46 SC45 SCMM6 SC44 SC43 SC42 SC41 C460 R696 R697 R698 Q783 Q784 C440 C809 C806 D725 C725 D773 Q781 C808 R777 Q652 C724 TPSC1 R652 IC724 Q679 R886 R888...
Page 74: Su-Board
TH-65PX600U 14.17. SU-Board Parts Location SU-BOARD IC6901 IC6902 IC6903 IC6904 IC6905 IC6906 IC6907 IC6908 IC6909 TPSU1 TPSU2 TPSU3 SU-BOARD (FOIL SIDE) TXNSU1EVTJ TNPA4009 1 SU SEE REVERSE FOR ORDER NO. SU-BOARD (COMPONENT SIDE) TXNSU1EVTJ R6938 C6964 C6980 C6981 C6966 C6969...
Page 75: Sd-Board
TH-65PX600U 14.18. SD-Board Parts Location SD-BOARD IC6910 IC6911 IC6912 IC6913 IC6914 IC6915 IC6916 IC6917 IC6918 TPSD1 TPSD2 TPSD3 SD-BOARD (FOIL SIDE) TXNSD1EVTJ TNPA4010 1 SD SEE R EVERSE FOR ORDER NO. SD-BOARD (COMPONENT SIDE) TXNSD1EVTJ R6964 C6991 C6975 D6922 C6974...
Page 76: Ss-Board
TH-65PX600U 14.19. SS-Board SS-BOARD (FOIL SIDE) TXNSS1EVTJ SS12 TP12 TP10 TP11 L241 L386 C263 C262 C261 C268 C267 C266 L272 D253 VR000 TP922 SS11 D152 D154 TP18 C224 C012 C011 D071 D024 TP20 Q045 Q044 Q043 Q042 Q041 Q256 C241...
Page 77 TH-65PX600U Parts Location Parts Location SS-BOARD (FOIL SIDE) SS-BOARD (COMPONENT SIDE) TP6904 TRANSISTOR TRANSISTOR Q6141 TP6905 Q6142 IC6131 Q6001 TP15V Q6001 TP6910 Q6143 IC6151 Q6002 Q6002 TPSOS7 TP6911 Q6144 IC6191 Q6003 TPSOS8 Q6003 TP6913 Q6146 IC6211 Q6004 TPSS1 Q6004 TP6918...
Page 78 TH-65PX600U SS-BOARD (COMPONENT SIDE) TXNSS1EVTJ C268 C261 SS12 SS11 Q251 D252 D251 R259 IC251 SSMM2 SSMM1 Q171 Q172 TPSOS8 R171 R172 R175 L386 R174 L272 Q222 R173 R176 L241 R258 Q173 Q174 D272 D271 TPSOS7 VR000 C033 R253 R252 D254...
Page 79: Ss2 And Ss3-Board
TH-65PX600U 14.20. SS2 and SS3-Board SS2-BOARD (FOIL SIDE) TNPA4013 TNPA4013 SEE REVERSE FOR ORDER NO. SS23 1 SS2 SS51 SS52 R6219 R6218 SS2-BOARD (COMPONENT SIDE) TNPA4013 SS2MM1 SS2MM2 TNPA4013 SS23 ORDER SS52 SS51 R6218 R6219 SS3-BOARD (FOIL SIDE) TNPA4014 R6221...
Page 80 TH-65PX600U NOTE...
Page 81: Schematic And Block Diagram
TH-65PX600U 15 Schematic and Block Diagram 15.1. Schematic Diagram Notes...
Page 82: Main Block Diagram
TH-65PX600U 15.2. Main Block Diagram S.R. S.R. S.R. S.R. S.R. S.R. S.R. S.R. S.R. S.R. S.R. S.R. S.R. S.R. S.R. POWER LED AI SENSOR POWER SW S VDA_75V VDA_75V VDA_75V DATA DRIVER(RIGHT) DATA DRIVER(CENTER) DATA DRIVER(LEFT) POWER LED REMOTE AI SENSOR...
Page 83: P-Board (1 Of 2) Block Diagram
TH-65PX600U 15.3. P-Board (1 of 2) Block Diagram COLD D1605 D1609 TO SC2 RF1601 3A Vsus 178V D1606 Vsus F201 T201 D251 R254 L1604 Q203 K1601 K1602 R257 VSUS F1601 D1603 D1604 D253 L1601 L1602 L1603 R1605 R1635 Q205 VR251...
Page 84: P-Board (2 Of 2) Block Diagram
TH-65PX600U 15.4. P-Board (2 of 2) Block Diagram Vda CONTROL MODULE MC401 <Exchange board only> RF1701 3A RECTIFIER Q405 Q406 TO P52 D1703 K1702 K1701 F1701 D1711 F301 L1702 L1701 IC01 AC_L D402 D1705 T301 Q301 R1761 L1703 R1740 R528...
Page 85: P-Board (1 Of 2) Schematic Diagram
TH-65PX600U 15.5. P-Board (1 of 2) Schematic Diagram COLD AC_IN SC-BOARD (SC2) SS-BOARD (SS11) P(P-1)-BOARD P(P-1)-BOARD (P51) (P55) Vsus POWER SUPPLY <Exchange board only> RELAY/ PFC CONTROL MODULE P(P-1)-BOARD <Exchange board only> (P53) COLD PFC MODULE <Exchange board only> P-BOARD ETXMM631MGHS (1/2)
Page 86: P-Board (2 Of 2) Schematic Diagram
TH-65PX600U 15.6. P-Board (2 of 2) Schematic Diagram COLD P-BOARD ETXMM631MGHS (2/2) SS-BOARD (SS12) Vda CONTROL MODULE <Exchange board only> P(P-2)-BOARD (P52) SS-BOARD (SS23) COLD PA-BOARD (PA5) Vda/STB POWER CONTROL MODULE <Exchange board only> PA-BOARD (PA10) COLD PFC MODULE <Exchange board only>...
Page 87: Pa-Board (1 Of 2) And H3-Board Block Diagram
TH-65PX600U 15.7. PA-Board (1 of 2) and H3-Board Block Diagram DC-DC CONVERTER/POWER SOS SPEAKER OUT/DIGITAL AUDIO PROCESSOR FAN CONTROL MAIN3.3V FACTORY 3.3V SRQ1 MAIN 3.3V Q2303 TO P5 +15V +15V +15V +15V +15V D2306 +15V D2307 IC2303 AVR 12V INPUT...
Page 88: Pa-Board (2 Of 2) Block Diagram
TH-65PX600U 15.8. PA-Board (2 of 2) Block Diagram IC5602 IC5601 AVR 3.3V/1.8V AVR 5V/9V MAIN3.3V MAIN3.3V PA10 TO P10 Q5610 ON/OFF1 VOUT1 ON/OFF1 VOUT1 F_STBY_15.5V TP16 TP16V MAIN5V F_STBY_15.5V MAIN1.8V SUB5V/MAIN5V MAIN5V ON/OFF2 VOUT2 F_STBY_15.5V Q5603 ON/OFF2 VOUT2 ON/OFF TUNER_MAIN_ON...
Page 89: Pa-Board (1 Of 3) Schematic Diagram
TH-65PX600U 15.9. PA-Board (1 of 3) Schematic Diagram IC5802 C0DBAYY00183 AVR 15V IC5601 FAN CONTROL AVR 5V/9V P-BOARD N0BG2DE00001 R5837 C5824 R5845 (P10) TP16 TP16V 0.1u IC5603 C5821 F_STBY_15.5V AVR 3.3V/1.8V R5836 0.01u 100k EHMDD9851 F_STBY_15.5V F_STBY_15.5V L5801 COMP 3.9u...
Page 90: Pa-Board (2 Of 3) Schematic Diagram
TH-65PX600U 15.10. PA-Board (2 of 3) Schematic Diagram PA-BOARD TXNPA1DRTU (2/3) IC5602 AVR 3.3V/1.8V EHMDD9851 L5607 14V_NR R5607 R5603 4.53k 15.4k C5699 C5673 0.1u C5611 C5616 LRCK 470u 0.1u R2355 DOUT SCKI MAIN3.3V DGND L5612 L5615 C2312 R2393 C5617 C5618 2.7u...
Page 91: Pa-Board (3 Of 3) And H3-Board Schematic Diagram
TH-65PX600U 15.11. PA-Board (3 of 3) and H3-Board Schematic Diagram Q2303 R2374 2SA207700L P-BOARD (P5) C2338 R2373 R2375 2.2k +15V 0.1u +15V R2377 D2307 2.2k MA2J11100L D2300 D2306 R2376 MA2J11100L C2337 MA2J11100L 0.1u L2308 Output 3.9u +15V Input C2395 C2385...
Page 92: H-Board Block Diagram
TH-65PX600U 15.12. H-Board Block Diagram IC2601 AV TERMINAL/AV SWITCH TO DG1 VIDEO SW MAIN_Y MAIN_PB MONITOR OUT YOUT1 JK2601 MONITOR MAIN Q2610 VOUT3 MAIN_PR PBOUT1 59 MONITOR MAIN_R_OPT PROUT1 58 MAIN_R MAIN_L_OPT MAIN_L V2_S_C YOUT2 SUB_Y V2_S_Y VIDEO2 PBOUT2 55...
Page 93: H-Board (1 Of 2) Schematic Diagram
TH-65PX600U 15.13. H-Board (1 of 2) Schematic Diagram H-BOARD TZRNA03DRTU (1/2) PA-BOARD (PA40) STB5V TP9V MAIN9V SUB5V SUB3.3V MAIN3.3V SUB9V C2735 C2732 C2776 C2746 C2795 100u 100u 100u 100u R2828 2.2k R2829 Q2632 Q2633 B1DHDC000028 R2831 B1ABCF000138 BT30V TP30V TP30...
Page 94: H-Board (2 Of 2) Schematic Diagram
TH-65PX600U 15.14. H-Board (2 of 2) Schematic Diagram C2797 25V 470u C2796 25V 470u C2635 JK2601 R2688 C2775 SUB9V MON_V 25V 470u R2686 K1U939A00003 MON_V D2656 R2691 MAZ81400ML MONITOR OUT D2657 Q2610 MON_SL MAZ81400ML MONITOR 2SB0709ASL D2658 MON_SR MAZ81400ML V2_S_C...
Page 95: G, Gk, K, R And S-Board Block Diagram
TH-65PX600U 15.15. G, GK, K, R and S-Board Block Diagram KEY SWITCH FRONT TERMINAL KEY2 /KEY_EDGE SW3755 SW3752 KEY1 VOL.DN TV GUIDE SW3756 SW3751 JK3701B VOL.UP MENU AV3 IN SW3757 SW3753 CH.DN SW3758 S-VIDEO CH.UP INPUT CY-G SW3754 TV/VTR V-SW...
Page 96: G, Gk, K, R And S-Board Schematic Diagram
TH-65PX600U 15.16. G, GK, K, R and S-Board Schematic Diagram COMPOSITE S-VIDEO INPUT INPUT JK3701B K4AK13B00001 AV3 IN GK-BOARD TXNGK1DRTU R3755 G-BOARD TXN/G1DRTU R3754 R3753 R3752 R3757 R3756 R3758 R3750 2.32k 1.62k 1.74k R3762 R3759 R3763 R3760 R3764 R3761 CH.UP CH.DN...
Page 97: Dg-Board (1 Of 4) And Gh-Board Block Diagram
TH-65PX600U 15.17. DG-Board (1 of 4) and GH-Board Block Diagram IC3801 HDMI EQ & SW GH HDMI IN 3 IC4029 DG DIGITAL SIGNAL PROCESSOR MAIN3.3V 2.5V BDT2P ADT2P DLL 2.5V MICOM BDT2N ADT2N BDT1P ADT1P HDMI INTERFACE VOUT TP3804 MAIN 5V...
Page 98: Dg-Board (2 Of 4) Block Diagram
TH-65PX600U 15.18. DG-Board (2 of 4) Block Diagram PA20 DG20 10 11 15 20 21 33 34 39 40 STBY3.3V IC4013 Q1142,Q1143 HDMI_CEC MAIN5V SUB5V SUB9V AD 3.3V MAIN2_1.8V AD 3.3V HDMI_CEC CECINA MAIN2_3.3V HDMI_SEL MAIN1.8V MAIN9V HDMI_SEL VOUT MAIN5V HDMI_WP MAIN3.3V...
Page 99: Dg-Board (3 Of 4) Block Diagram
TH-65PX600U 15.19. DG-Board (3 of 4) Block Diagram IC1103 MAIN MICOM 107 105 209 211 63 78 62 IC1101 X1100 X1101 FLASH RESET FIFO FOR IP IC1602 FIFO FOR BNR IC1603 DI0-DI31 DI0-DI31 IC1604 DO0-DO31 DO0-DO31 32M FIFO 32M FIFO...
Page 100: Dg-Board (4 Of 4) Block Diagram
TH-65PX600U 15.20. DG-Board (4 of 4) Block Diagram 23 22 STBY5V FACTORY HC01 D_15V D_IIC_CONT IIC_CONT D_SCL2 IIC_CLK2 D_SDA2 IIC_DATA2 D_TXD IC1103 D_RXD D_IIC_INT IIC/INT MAIN MICOM D_PSTB PSTB D_PBUSY PBUSY D_PDB0 PDB0 D_PSLCT PSLCT D_PDB1 PDB1 CFG_TDI_A CFG_TMS_A CFG_TCK_A...
Page 101: Dg-Board (1 Of 11) Schematic Diagram
TH-65PX600U 15.21. DG-Board (1 of 11) Schematic Diagram DG-BOARD TZRNA02DRTU (1/11) D-BOARD (D3) D_IIC_CONT IIC_CONT D_IIC_INT IIC_INT D_SCL2 IIC_CLK2 D_SDA2 IIC_DATA1 R1458 R1102 DISPEN DISPEN PANEL_STATUS READY R1103 PANEL_SOS ALARM INEXCH R1459 PANEL_STBY_ON PANEL_STBY_ON STBY5V_F STBY5V D_RXD D_15V P15V D_TXD...
Page 102: Dg-Board (2 Of 11) Schematic Diagram
GENX_CLKIN IC1106 MAIN3.3V C0JBAS000128 R1171 SWITCHING R1232 3.3k R1233 3.3k R1235 2.7k R1236 2.7k SUB9V TP1110 R1451 R1450 R1524 3.9k 6.8k DG-BOARD TZRNA02DRTU (2/11) TP1106 R1281 TH-65PX600U DG-Board (2 of 11) Schematic Diagram TH-65PX600U DG-Board (2 of 11) Schematic Diagram...
Page 103: Dg-Board (3 Of 11) Schematic Diagram
C1233 KEY3_KEY_EDGE SUB9V R1428 KEYSCAN3 PSM_LEDR_AFC1_KEY2 SUB9V KEYSCAN2 C1234 SUB9V R1488 MAIN2_3.3V MAIN2_3.3V MAIN2_3.3V R1953 MAIN2_3.3V C1920 220u R1954 MAIN2_1.5V TP1906 MAIN2_1.5V R1952 MAIN2_1.5V C1919 MAIN2_1.5V TH-65PX600U DG-Board (3 of 11) Schematic Diagram TH-65PX600U DG-Board (3 of 11) Schematic Diagram...
Page 104: Dg-Board (4 Of 11) Schematic Diagram
JS4020 5600p 2SA207700L C4220 C4225 JS4021 0.01u R4548 C4252 C4214 VOUT IC4040 C0CBCAC00282 IC4017 VOUT MAIN3.3V MAIN 2.5V C0CBCAC00282 MAIN3.3V JS4113 PLL 2.5V C4009 C4234 0.1u TH-65PX600U DG-Board (4 of 11) Schematic Diagram TH-65PX600U DG-Board (4 of 11) Schematic Diagram...
Page 105: Dg-Board (5 Of 11) Schematic Diagram
R1913 CLK- C1911 CLKG 0.1u CLK+ R1914 IC1903 R1915 C1AB00002641 R1916 R1931 HDMI EQ & SW 4.7k R1917 C1914 R1918 0.1u R1919 R1920 DG-BOARD TZRNA02DRTU (5/11) TH-65PX600U DG-Board (5 of 11) Schematic Diagram TH-65PX600U DG-Board (5 of 11) Schematic Diagram...
Page 106: Dg-Board (6 Of 11) Schematic Diagram
AUDIO DAC 180p C4352 0.01u R4591 R4679 R4036 HDMI_R_AUDIO HDMI_R C4345 R4675 R4592 6.3V R4593 R4681 R4594 R4595 R4596 H=Mute/L=Normal HDMI_5V_DET1 HDMI_5V_DET2 HDMI_CEC R4101 Q4084 HDMI_WP B1ABDF000034 TH-65PX600U DG-Board (6 of 11) Schematic Diagram TH-65PX600U DG-Board (6 of 11) Schematic Diagram...
Page 107: Dg-Board (7 Of 11) Schematic Diagram
1000p 0.1u L4063 R4736 A_DDR_DQ18 A_DDR_DQ2 G1C100KA0009 IC4037 AJ12 DQ18 IC4037 AJ16 A_DDR_DQ17 A_DDR_DQ1 IC4037 AH13 DQ17 IC4037 AK16 A_DDR_DQ16 A_DDR_DQ0 IC4037 AJ13 DQ16 IC4037 AH16 TH-65PX600U DG-Board (7 of 11) Schematic Diagram TH-65PX600U DG-Board (7 of 11) Schematic Diagram...
Page 108: Dg-Board (8 Of 11) Schematic Diagram
B_DDR_DQ16 B_DDR_DQ0 B_DDR_DQS0 R4793 22 A_DDR_CLK B_DDR_CLK IC4038 IC4038 DQ16 IC4038 IC4038 DQS0 A_DDR_DQS1 B_DDR_DQS1 FL4010 R4794 22 A_DDR_NCLK B_DDR_NCLK MAIN_R J0HABH000012 R4779 SUB5V FL4011 J0HABH000012 TH-65PX600U DG-Board (8 of 11) Schematic Diagram TH-65PX600U DG-Board (8 of 11) Schematic Diagram...
Page 109: Dg-Board (9 Of 11) Schematic Diagram
IC1401 B1CBHD000002 B1CBHD000002 IC1401 VCCO_6 IC1401 VCCO_8 IC1401 IC1401 AF13 IC1401 IC1401 R1440 27MHz IC1401 IC1401 AF14 IC1401 IO_L3P_GC_LC_3 REFCK_FS IC1401 IC1401 AF25 DG-BOARD TZRNA02DRTU (9/11) TH-65PX600U DG-Board (9 of 11) Schematic Diagram TH-65PX600U DG-Board (9 of 11) Schematic Diagram...
Page 110: Dg-Board (10 Of 11) Schematic Diagram
INIT_B_0 CFG_TDO_3E C1ZBZ0003448 SPAR_TMP1 R1496 IC1401 TDI_0 IC1401 IO_L7N_6 CFG_DONE FPGA1 SPAR_TMP0 R1497 IC1401 DONE_0 IC1401 IO_L9N_CC_LC_6 CFG_RST_2 FPGA2 Virtex4-SX25 IC1401 PROGRAM_B_0 Spartan3E-1600 DG-BOARD TZRNA02DRTU (10/11) TH-65PX600U DG-Board (10 of 11) Schematic Diagram TH-65PX600U DG-Board (10 of 11) Schematic Diagram...
Page 111: Dg-Board (11 Of 11) Schematic Diagram
0.1u IC1501 IO_L14P_0/GCLK10 IC1501 VCCO_3 0.1u 27MHz C1690 IC1501 VCCINT C1672 IC1501 VCCO_3 0.1u 0.1u C1691 IC1501 VCCINT 0.1u C1692 IC1501 VCCINT 0.1u DG-BOARD TZRNA02DRTU (11/11) TH-65PX600U DG-Board (11 of 11) Schematic Diagram TH-65PX600U DG-Board (11 of 11) Schematic Diagram...
Page 112: Gh-Board Schematic Diagram
TH-65PX600U 15.32. GH-Board Schematic Diagram GH-BOARD TXNGH1DRTU R3802 Q3802 B1ABDF000034 D3814 C3824 C3823 D3813 Vcc2 B0HCMM000014 B0HCMM000014 0.1u 0.1u TP3803 SCLOUT SDAOUT SCLIN SDAIN L3802 ERJ3GEYJ560V L3803 ERJ3GEYJ560V R3805 IC3803 4.7k L3805 R3815 J0JHC0000078 C0ZBZ0001038 TP3804 C3813 C3814 5V<->3.3V C3818 C3811 6.3V...
Page 113: Dt-Board (1 Of 2) And Gs-Board Block Diagram
TH-65PX600U 15.33. DT-Board (1 of 2) and GS-Board Block Diagram XF8202 IC8211 COMB FILTER ATSC INTERFACE FRONT PROCESSOR (TERRESTRIAL RECEIVER) 9V_SUB 9V_POWER IC8245 9V_SUB 9V_POWER IC8057 D8203 D8204 DC-DC CONVERTER IBFSYNC DC-DC CONVERTER 5V_SUB 1.5V 5V_SUB MPEG_CLK 1.2V FDC_P IF AMP...
Page 114: Dt-Board (2 Of 2) Block Diagram
TH-65PX600U 15.34. DT-Board (2 of 2) Block Diagram 5V_SUB DT07 DT04 Cable CARD DT08 SUPPORT HC06 +3.3V CARD SBI0 3.3V 5V_SUB SBO0 VPPOUT EN_VPP3 IC8216 D0-D2 3.3V EN_VPP5 +3.3V VPPOUT XVBIRST IC8250 MPEG_CLK D3-D7 XVBIRST POD ASIC DATA BUS 3VIN...
Page 115: Dt-Board (1 Of 9) Schematic Diagram
TH-65PX600U 15.35. DT-Board (1 of 9) Schematic Diagram DT-BOARD TNAG171S (1/9) LOCATION RIGHT-DOWN RIGHT-UP LEFT-DOWN CENTER-UP LEFT-UP R8614 R8631 R8596 R8602 R8608 R8615 R8632 R8597 R8603 R8609 R8616 R8633 R8598 R8604 R8610 R8617 R8634 R8599 R8605 R8611 R8629 R8635 R8600...
Page 116: Dt-Board (2 Of 9) Schematic Diagram
TH-65PX600U 15.36. DT-Board (2 of 9) Schematic Diagram DT-BOARD TNAG171S (2/9) C8338 0.1u AP_AGC_CONT R8317 R8282 AA_ED16 AC_MDO2(D10) AA_ED17 AA_ED18 AC_MOVAL(BVD2) OBDACMP OBPGAEN OBQTX C8368 AA_ED19 AC_MDO3(D11) 112 ED3 VDDA0 OBPGASCL VSS16 MOD_MDO3 CLKSEL 2.5V C8306 0.1u AA_ED20 R8391 AC_MDO4(D12)
Page 117: Dt-Board (3 Of 9) Schematic Diagram
TH-65PX600U 15.37. DT-Board (3 of 9) Schematic Diagram DT-BOARD TNAG171S (3/9) 5V_SUB 3.3V 5V_SUB R8624 Q8208 R8402 B1ADDF000005 Q8207 AA_XVBIIRQ L8281 B1ABDF000034 C8398 R8625 J0JHC0000078 AD_IRSYS IR BLASTER 3.3V C8395 6.3V R8628 Q8236 R8623 6.3V JK8200 R8348 B1ABDF000034 K2HC104B0028 C8493...
Page 118: Dt-Board (4 Of 9) Schematic Diagram
TH-65PX600U 15.38. DT-Board (4 of 9) Schematic Diagram DT-BOARD TNAG171S (4/9) AA_DACRST AA_NTSCRST AA_XVBIRST R8189 C8038 R8191 EXB2HV100JV 0.1u R8543 IC8038 AA_FORMATEDGE 128 WORK CPU FLASH TVRP113S 5V_SUB R8517 EXB38V103JV R8061 C8285 C8430 C8284 0.1u 0.1u 0.1u C8437 R8505 R8412 TO SUPPORT CARD 0.1u...
Page 119: Dt-Board (5 Of 9) And Gs-Board Schematic Diagram
TH-65PX600U 15.39. DT-Board (5 of 9) and GS-Board Schematic Diagram SD CARD SLOT RESET GS-BOARD TXNGS1DRTU K1NA09E00080 IC8042 9V_SUB FL8017 FL8018 3.3V J0HAAA000013 J0HAAA000013 C0EBM0000026 JK7701 R7716 9V_SUB R8671 R8672 Q8026 5.6k R7703 AA_SDDAT2 SDDAT2 R8658 HIGH:LED ON Q8027 B1ABDF000034...
Page 120: Dt-Board (6 Of 9) Schematic Diagram
TH-65PX600U 15.40. DT-Board (6 of 9) Schematic Diagram DT-BOARD TNAG171S (6/9) IC8016 IC8013 IC8013 C3ABQG000075 IC8013 AP_VCMOS 128M D-RDRAM RAMBUS MEMORY I/F IC8013 MN2WS012AA-A IC8013 IC8013 3.3V IC8013 C8139 IC8013 L8030 IC8013 DQA7 DQA4 CFMN DQB0 DQB4 DQB7 R8178 J0JHC0000045...
Page 121: Dt-Board (7 Of 9) Schematic Diagram
TH-65PX600U 15.41. DT-Board (7 of 9) Schematic Diagram R8565 DT-BOARD TNAG171S (7/9) IC8025 C3EBJC000055 3.3V R8154 C8270 0.01u TP8243 R8666 AD_SCL1 TP8242 AD_SDA1 R8667 IC8023 EEPROM 64kbit C0ZBZ0001327 400MHz Direct Rambus Clock Generator C8094 C8095 0.1u 0.1u C8096 C8080 0.1u 10V 0.1u...
Page 122: Dt-Board (8 Of 9) Schematic Diagram
TH-65PX600U 15.42. DT-Board (8 of 9) Schematic Diagram DT-BOARD TNAG171S (8/9) IC8030 C1AB00001857 3.3V AM_SVCLKO NTSC ENCODER L8043 C8106 C8146 J0JHC0000045 6.3V 0.01u AM_SVD7 AM_SVD6 AM_SVD5 SYSINV AM_SVD4 C8147 DVDD DVDD 0.01u DVSS DVSS AM_SVD3 IREF DT12 DG-BOARD AM_SVD2 AVSS...
Page 123: Dt-Board (9 Of 9) Schematic Diagram
TH-65PX600U 15.43. DT-Board (9 of 9) Schematic Diagram DT-BOARD TNAG171S (9/9) 9V_POWER 9V_SUB L8103 G1C100MA0203 5V_SUB 5V_SUB 3.3V 9V_SUB C8509 C8510 L8106 C8496 C8502 J0JHC0000075 R8575 C8252 C8255 C8256 C8257 C8258 C8260 C8547 C8548 C8549 C8420 C8421 C8422 C8423 C8475...
Page 124: D-Board (1 Of 2) Block Diagram
TH-65PX600U 15.44. D-Board (1 of 2) Block Diagram DIGITAL SIGNAL PROCESSOR FORMAT CONVERTER PLASMA AI SUB-FIELD PROCESSOR PICTURE OUTPUT<R> R 10bit R10-R19(R) G 10bit G10-G19(R) TO DG5 B 10bit B10-B19(R) E+LVDS0 (RX_TA+) E-LVDS0 (RX_TA-) E+LVDS1 (RX_TB+) E-LVDS1 (RX_TB-) BUS SW...
Page 125: D-Board (2 Of 2) Block Diagram
TH-65PX600U 15.45. D-Board (2 of 2) Block Diagram R-UP IC9401 TO C10 D DIGITAL SIGNAL PROCESSOR DDR SDRAM<R>(128M) 30bit UA06-UC15<R> DOUTU31C FORMAT CONVERTER IC9400 PD1-M<RIGHT> PLASMA AI FORMAT CONVERTER/RGB PROCESSOR<R> PLASMA AI/SUB FIELD PROCESSOR/DATA DRIVER<R> DOUTU22A SUB-FIELD PROCESSOR DRVCLKU0-U3,DRVCLKD0-D3<R> CLKU3...
Page 126: D-Board (1 Of 8) Schematic Diagram
TH-65PX600U 15.46. D-Board (1 of 8) Schematic Diagram FL9803 J0HABH000012 D-BOARD TZTNP01DRTU (1/8) P-BOARD (P25) P15V P15V PA9800 K5H4022A0023 P15V +15V FL9804 C9823 C9844 J0HABH000012 C9833 C9817 +15V 0.01u C9808 C9807 FAN_CONT R9802 LDO_5V R9880 LDO_5V D9813 FL9805 B0JCDD000002 J0HABH000013...
Page 127: D-Board (2 Of 8) Schematic Diagram
TH-65PX600U 15.47. D-Board (2 of 8) Schematic Diagram D-BOARD TZTNP01DRTU (2/8) STB3.3V P3.3V STB3.3V P15V STB3.3V R9203 R9218 R9217 R9215 R9205 DG-BOARD STB 3.3V R9221 R9220 4.7k (DG5) RESET IC9011 R9207 R9206 STB5V_M STB5V C0EBF0000431 STB3.3V D9110 R9140 R9222 B0JCGD000002...
Page 128: D-Board (3 Of 8) Schematic Diagram
TH-65PX600U 15.48. D-Board (3 of 8) Schematic Diagram P3.3V FL9504 P3.3V VCCINT F1J1E1040022 LVDS_INPUT VCCI L8L1.2V FPGA SC_PULSE C9531 R9529 6.3V C9516 IC9500 IC9500 0.1u FP_CL R9604 IC9500 VCCIO2 IC9500 LVDS_DET D-BOARD TZTNP01DRTU (3/8) IC9500 LVDS_DET IC9500 IC9500 FP_CLK IC9500...
Page 129: D-Board (4 Of 8) Schematic Diagram
TH-65PX600U 15.49. D-Board (4 of 8) Schematic Diagram C9557 C9515 D-BOARD TZTNP01DRTU (4/8) C9514 DD_ODEU DD_ODED FP_URH/CBK *R9605 D_ODEU1 D_ODED5 FP_UEH DD_LEUR D_ODEU2 DD_LEDL D_ODED6 FP_USL DD_LEUL D_LEU1 DD_LEDR D_LED5 FP_USH DD_PCU1 D_LEU2 DD_PCD1 D_LED6 FP_UML DD_PCU2 D_PCU1 DD_PCD2 D_PCD5...
Page 130: D-Board (5 Of 8) Schematic Diagram
TH-65PX600U 15.50. D-Board (5 of 8) Schematic Diagram D-BOARD TZTNP01DRTU (5/8) IC9400 FORMAT CONVERTER/RGB PROCESSOR<R> PLASMA AI/SUB FIELD PROCESSOR/DATA DRIVER<R> MN84521A-A Right from FPGA1 to DDR to DISCHARGE CONTROL FPGA XRST2 C9463 L8L3.3V L8R_DCK IC9400 XRST IC9400 L8R_DQ0 IC9400 FPCLK...
Page 131: D-Board (6 Of 8) Schematic Diagram
TH-65PX600U 15.51. D-Board (6 of 8) Schematic Diagram C1-BOARD (C10) DDR-SDRAM R TERM IC9401 VSS_Thermal IC9401 VSSQ IC9401 IC9401 VSS_Thermal IC9401 VSSQ IC9401 L8L2.5V FL9307 J0HABH000013 IC9401 VSS_Thermal C9111 IC9401 VSSQ IC9401 IC9401 VSS_Thermal IC9401 VSSQ IC9401 C9086 0.1u IC9401...
Page 132: D-Board (7 Of 8) Schematic Diagram
TH-65PX600U 15.52. D-Board (7 of 8) Schematic Diagram C2-BOARD (C24) TERM D-BOARD TZTNP01DRTU (7/8) FL9308 J0HABH000013 TP9533 P3.3V P3.3V R9400 D9300 R9452 MA3X152K0L D9301 MA3X152K0L R9398 R9450 4.7k 4.7k C9369 C9370 R9399 Q9300 Q9301 R9451 100k 0.01u B1ABCF000138 100k B1ABCF000138 0.01u...
Page 133: D-Board (8 Of 8) Schematic Diagram
TH-65PX600U 15.53. D-Board (8 of 8) Schematic Diagram C2-BOARD (C25) D-BOARD TZTNP01DRTU (8/8) TERM FL9309 J0HABH000013 TP9462 P3.3V R9461 D9302 MA3X152K0L R9459 4.7k C9371 Q9302 R9460 B1ABCF000138 ZA9001 100k 0.01u K4CD01000011 DDR-SDRAM L IC9301 VSS_Thermal IC9301 VSSQ IC9301 IC9301 VSS_Thermal...
Page 134: C1, C2, C5 And C6-Board Block Diagram
TH-65PX600U 15.54. C1, C2, C5 and C6-Board Block Diagram DOUTU31C DOUTU22A DOUTU21C DOUTU10A TO D31 TO D32 31,41 11 10 31,41 DATA DATA DATA DATA DATA 6bit 8bit 8bit 8bit 6bit P+5V UA10 UA20 UB17 UA14 UA12 R7186 P+5V UC21...
Page 135: C2, C3, C4, And C5 Block Diagram
TH-65PX600U 15.55. C2, C3, C4, and C5 Block Diagram DOUTU0A DOUTU9C TO D33 31,41 DATA DATA DATA DATA P+5V P+5V 8bit 8bit 8bit 6bit R7387 R7386 P+5V VDA_75V TO SS35 Vda 75V P+5V CLRU2 Vda 75V 5V_DET PCU2 LEU2 Vda 75V...
Page 136: C1-Board (1 Of 2) Schematic Diagram
D7119 C7172 C7173 100V B0HCMM000014 100V 0.47u 0.47u D7120 B0HCMM000014 R7137 R7139 R7136 R7138 C1_5V C7187 C7176 PANEL DATA DRIVER C1-BOARD TXNC11EVTJ (1/2) TERM C7170 TH-65PX600U 100p C1-Board (1 of 2) Schematic Diagram TH-65PX600U C1-Board (1 of 2) Schematic Diagram...
Page 137: C1-Board (2 Of 2) Schematic Diagram
TH-65PX600U 15.57. C1-Board (2 of 2) Schematic Diagram R7156 R7153 EXB38V681JV EXB38V681JV R7159 EXB38V470JV C1-BOARD TXNC11EVTJ (2/2) AB_DUA22 AB_DUB22 AA_DUA22 AA_DUB22 R7158 EXB38V470JV AB_DUC22 AA_DUC22 AB_DUA23 AA_DUA23 AB_DUB23 AB_DUC23 AA_DUB23 AA_DUC23 C1_5V C7138 OE1 1 0.1u R7144 R7143 EXB38V681JV EXB38V681JV...
Page 138: C2-Board (1 Of 2) Schematic Diagram
TH-65PX600U 15.58. C2-Board (1 of 2) Schematic Diagram C2-BOARD TXNC21EVTJ (1/2) VDA_75V VDA_75V D7211 D7215 B0HCMM000014 B0HCMM000014 C7213 C7214 C7222 C7226 100V 100V 100V 100V 0.47u 0.47u 0.47u 0.47u D7216 D7212 B0HCMM000014 B0HCMM000014 C7203 C7200 C7224 C7205 PANEL DATA DRIVER...
Page 139: C2-Board (2 Of 2) Schematic Diagram
TH-65PX600U 15.59. C2-Board (2 of 2) Schematic Diagram C2-BOARD TXNC21EVTJ (2/2) VDA_75V D7219 B0HCMM000014 C7286 C7287 100V 100V 0.47u 0.47u ZA7201 ZA7206 ZA7205 K4AD01Z00001 K4AD01Z00001 K4AD01Z00001 C1-BOARD (C11) VDA_75V ZA7202 ZA7203 ZA7204 K4AD01Z00001 K4AD01Z00001 K4AD01Z00001 D7220 P75V B0HCMM000014 C7285 C7209...
Page 140: C3-Board (1 Of 2) Schematic Diagram
TH-65PX600U 15.60. C3-Board (1 of 2) Schematic Diagram C3-BOARD TXNC31EVTJ (1/2) D7311 VDA_75V B0HCMM000014 C3_5V C7328 C7325 100V 100V C7308 0.47u 0.47u 0.1u AA_DUC9 AA_DUB9 AB_DUC9 AB_DUB9 AA_DUA9 AB_DUA9 AA_DUC8 AB_DUC8 D7312 AA_DUB8 R7311 EXB38V470JV B0HCMM000014 AA_DUA8 AB_DUB8 C7382 C7316...
Page 141: C3-Board (2 Of 2) Schematic Diagram
TH-65PX600U 15.61. C3-Board (2 of 2) Schematic Diagram VDA_75V C3-BOARD TXNC31EVTJ (2/2) D7315 B0HCMM000014 C7331 C7333 100V 100V 0.47u 0.47u D7316 B0HCMM000014 C7384 C7340 C3_5V PANEL DATA DRIVER TERM R7374 R7384 C7351 100p VDA_75V D7317 B0HCMM000014 C7332 C7334 100V 100V 0.47u...
Page 142: C4-Board (1 Of 2) Schematic Diagram
TH-65PX600U 15.62. C4-Board (1 of 2) Schematic Diagram C4-BOARD TXNC41EVTJ (1/2) VDA_75V C4_5V C7480 C4_5V 16V 0.1u SS-BOARD SS-BOARD (SS42) (SS44) AA_ODED4 AA_CLRD4 AB_ODED4 AB_CLRD4 R7402 AA_PCD4 AB_PCD4 AA_LED4 LE11 R7438 EXB38V470JV LE12 LE13 R7474 LE14 EXB38V681JV LE15 R7439 ZA7403...
Page 143: C4-Board (2 Of 2) Schematic Diagram
TH-65PX600U 15.63. C4-Board (2 of 2) Schematic Diagram C7475 C4-BOARD TXNC41EVTJ (2/2) 100p R7422 R7434 PANEL DATA R7472 DRIVER C4_5V C7472 C7485 D7423 B0HCMM000014 R7433 R7432 R7431 R7430 VDA_75V D7424 B0HCMM000014 C7468 C7469 100V 100V 0.47u 0.47u C7453 100p R7477...
Page 144: C5-Board (1 Of 2) Schematic Diagram
TH-65PX600U 15.64. C5-Board (1 of 2) Schematic Diagram D-BOARD (D35) C5-BOARD TXNC51EVTJ (1/2) TERM R7592 100k C5_5V R7593 FL7501 J0HABH000013 C5_5V C5_5V C5_5V C5_5V C7575 C7577 C7513 C7530 16V 0.1u 0.1u 0.1u 0.1u AA_ODED5 AA_DDA21 AA_DDB16 AA_DDB21 AA_DDC16 AA_CLRD5 AB_ODED5...
Page 145: C5-Board (2 Of 2) Schematic Diagram
TH-65PX600U 15.65. C5-Board (2 of 2) Schematic Diagram D-BOARD (D34) TERM C5-BOARD TXNC51EVTJ (2/2) C5_5V FL7502 J0HABH000013 C5_5V C7508 16V 0.1u C5_5V C5_5V C5_5V C7527 C7519 C7538 USH_N UML_N 0.1u 0.1u 0.1u AA_DDC15 AA_DDA13 AA_DDA11 UMH_N NUEL NUEL_N AA_DDA14 AB_DDC15...
Page 146: C6-Board (1 Of 2) Schematic Diagram
TH-65PX600U 15.66. C6-Board (1 of 2) Schematic Diagram C6-BOARD TXNC61EVTJ (1/2) ZA7606 ZA7604 ZA7605 K4AD01Z00001 K4AD01Z00001 K4AD01Z00001 ZA7601 ZA7602 ZA7603 K4AD01Z00001 K4AD01Z00001 K4AD01Z00001 C7611 100p R7616 R7604 R7618 PANEL DATA DRIVER C6_5V C7601 D7614 C7667 B0HCMM000014 R7612 R7609 R7608 R7613...
Page 147: C6-Board (2 Of 2) Schematic Diagram
TH-65PX600U 15.67. C6-Board (2 of 2) Schematic Diagram D-BOARD (D36) C7661 100p R7660 TERM R7665 FL7601 J0HABH000013 C6_5V R7686 C6_5V R7687 100k PANEL DATA DRIVER R7696 EXB38V681JV C7658 C7669 D7620 B0HCMM000014 R7664 R7663 R7662 R7661 AB_NCLK71R R7606 AB_CLK61R R7605 AB_NCLK72R...
Page 148: Sc-Board Block Diagram
TH-65PX600U 15.68. SC-Board Block Diagram SC SCAN DRIVE +16V_F VOUT TPSC1 SIGNAL WAVE VSUS IC6791 VSET 240V TO P2 TPVSUS VSET DC/DC CONV. VSET Gen. 178V COLD FLOATING GND TPVSET Vsus Q6821,Q6822 VSUS IC6821 VSET SOS operates TO SU45 15V_F at 156V or less.
Page 149: Th-65Px600U
TH-65PX600U 15.69. SC-Board (1 of 4) Schematic Diagram C6532 C6533 C6534 250V 250V 250V R6468 R6467 C6535 C6536 C6537 C6538 250V 250V 250V 250V R6466 L6461 G0ZZ00002183 D6466 R6465 MA2J11100L L6462 G0ZZ00002183 TPVSUS L6591 D6461 P-BOARD L6463 G0ZZ00002183 VSUS G0ZZ00002183...
Page 150: Sc-Board (2 Of 4) Schematic Diagram
TH-65PX600U 15.70. SC-Board (2 of 4) Schematic Diagram VSUS SC-BOARD TXNSC1EVTJ (2/4) IC6721 COLD FLOATING GND C0JBAZ000994 Q6401 Q6405 BUFFER R6721 PC6701 2PG0010000RP 2PG0010000RP EXB38V220JV Q6501 Q6505 B3PBA0000233 AB_FCLD R6401 R6405 B1ABNF000006 B1ABNF000006 C6405 AB_FCLU 630V 5600p AB_FCLKD C6726 R6700...
Page 151: Sc-Board (3 Of 4) Schematic Diagram
TH-65PX600U 15.71. SC-Board (3 of 4) Schematic Diagram SC-BOARD TXNSC1EVTJ (3/4) FLOATING GND COLD SOS7_SC2 R6633 R6632 D6616 4.7k 3.9k MA2J11100L PC6610 B3PBA0000223 COLD FLOATING GND L6680 TPSC1 VSCN_F G0ZZ00002183 IC6682 C6703 0.1u IC6681 PC6703 C0JBAA000377 R6683 R6696 D6682 B3PBA0000233...
Page 152: Sc-Board (4 Of 4) Schematic Diagram
TH-65PX600U 15.72. SC-Board (4 of 4) Schematic Diagram SU-BOARD SU-BOARD SC41 (SU41) SC42 (SU42) SC-BOARD TXNSC1EVTJ (4/4) SU-BOARD (SU45) IC6791 VSET TP40 Q6821 AB_FSIU DC/DC CONV. VSET0 VSET:240V N0BF1FB00001 2SD1263AP0LB AB_FSIU D6822 TP41 R6821 MA2J11100L D6824 R6829 AB_FCLU R6825 C6822...
Page 153: Su And Sd-Board Block Diagram
TH-65PX600U 15.73. SU and SD-Board Block Diagram VDDH VDDH IC6901 LINE IC6918 LINE 64bit 64bit VDDH IC6902 VDDH IC6917 64bit 64bit VDDH VDDH IC6903 LINE IC6916 LINE 64bit 64bit VDDH IC6940 IC6904 VDDH TO SC45 IC6920 IC6915 TO SC46 FSIU...
Page 154: Su-Board (1 Of 3) Schematic Diagram
TH-65PX600U 15.74. SU-Board (1 of 3) Schematic Diagram SU-BOARD TXNSU1EVTJ (1/3) To 5th 108pins of SCAN ELECTRODES AB539 AC486 AC475 AB538 AC487 AC474 AB537 AC488 AC473 AB536 AC489 AC472 OUT41 OUT35 OUT30 OUT24 OUT41 OUT35 OUT30 OUT24 AB535 AC490 AC471...
Page 155: Su-Board (2 Of 3) Schematic Diagram
TH-65PX600U 15.75. SU-Board (2 of 3) Schematic Diagram SU-BOARD TXNSU1EVTJ (2/3) To 3rd 108pins of To 4th 108pins of SCAN ELECTRODES SCAN ELECTRODES AD422 AD411 AE358 AE347 AF294 AF283 AD423 AD410 AE359 AE346 AF295 AF282 AD424 AD409 AE360 AE345 AF296...
Page 156: Su-Board (3 Of 3) Schematic Diagram
TH-65PX600U 15.76. SU-Board (3 of 3) Schematic Diagram SU-BOARD TXNSU1EVTJ (3/3) To 2nd 108pins of To 1st 108pins of SCAN ELECTRODES SCAN ELECTRODES AG230 AG219 AH166 AH155 AI102 AI91 AJ38 AJ27 AG231 AG218 AH167 AH154 AI103 AI90 AJ39 AJ26 AG232...
Page 157: Sd-Board (1 Of 3) Schematic Diagram
TH-65PX600U 15.77. SD-Board (1 of 3) Schematic Diagram SD-BOARD TXNSD1EVTJ (1/3) To 1st 108pins of To 2nd 108pins of SCAN ELECTRODES SCAN ELECTRODES AB1054 AB1043 AC990 AC979 AD926 AD915 AE862 AE851 AB1055 AB1042 AC991 AC978 AD927 AD914 AE863 AE850 AB1056...
Page 158: Sd-Board (2 Of 3) Schematic Diagram
TH-65PX600U 15.78. SD-Board (2 of 3) Schematic Diagram SD-BOARD TXNSD1EVTJ (2/3) To 3rd 108pins of To 4th 108pins of SCAN ELECTRODES SCAN ELECTRODES AF798 AF787 AG734 AG723 AH670 AH659 AF799 AF786 AG735 AG722 AH671 AH658 AF800 AF785 AG736 AG721 AH672...
Page 159: Sd-Board (3 Of 3) Schematic Diagram
TH-65PX600U 15.79. SD-Board (3 of 3) Schematic Diagram SD-BOARD TXNSD1EVTJ (3/3) To 5th 108pins of SCAN ELECTRODES AI606 AI595 AJ542 AI607 AI594 AJ543 AI608 AI593 AJ544 AI609 AI592 AJ545 OUT41 OUT24 OUT41 OUT24 OUT35 OUT30 OUT35 OUT30 AI610 AI591 AJ546...
Page 160: Ss, Ss2 And Ss3-Board Block Diagram
TH-65PX600U 15.80. SS, SS2 and SS3-Board Block Diagram TO P12 TO P11 TPVSUS SS51 SUSTAIN DRIVE NO USE Q6001-Q6004 Q6005-Q6008 OUTPUT OUTPUT Q6141- Q6151- STB PS Q6144 Q6154 Vsus Gen. STB_12V BUFFER BUFFER IC6131 TP15V SS52 FET DRIVER OUTPUT OUTPUT...
Page 161: Ss-Board (1 Of 2) Schematic Diagram
DRV_SOS7 L6241 D6253 G0ZZ00002183 R6253 R6255 LNJ301MPUJA 1.2k (GREEN LED) R6258 D6255 2.2k MA2J11100L C6251 TPSOS8 R6254 6.8k TPSOS7 R6256 1.5k IC6251 D6254 MAZ80510LL C0BBBA000022 COMPARATOR TH-65PX600U SS-Board (1 of 2) Schematic Diagram TH-65PX600U SS-Board (1 of 2) Schematic Diagram...
Page 162: Ss-Board (2 Of 2), Ss2 And Ss3-Board Schematic
R6120 R6215 R6291 Q6116 2.49k IC6281 Q6212 B1DFKM000002 TP24 TP25 TP26 TP27 TP28 TP29 TP30 TP31 R6217 B1ADNF000006 C0DBEMB00005 R6216 TH-65PX600U SS-Board (2 of 2), SS2 and SS3-Board Schematic Diagram TH-65PX600U SS-Board (2 of 2), SS2 and SS3-Board Schematic Diagram...
Page 163: Parts Location & Mechanical Replacement Parts List
TH-65PX600U 16 Parts Location & Mechanical Replacement Parts List 16.1. Parts Location...
Page 164: Packing Exploded Views
TH-65PX600U 16.2. Packing Exploded Views...
Page 165: Packing Exploded Views
TH-65PX600U 16.3. Packing Exploded Views...
Page 166: Mechanical Replacement Parts List
TH-65PX600U 16.4. Mechanical Replacement Parts List Note: Ref. No. Part No. Part Name & Remarks Description All parts except parts mentioned [PAVCA] in the Remarks TPDA1208 ESC PROTECTION column are supplied by PAVC-CSG. BOTTOM TQB2AA0731 INSTRUCTION BOOK Parts mentioned [PAVCA] are supplied by PAVCA.
Page 167: Electrical Replacement Parts List
TH-65PX600U 17 Electrical Replacement Parts List 17.1. Replacement Parts List Notes...
Page 168: Electrical Replacement Parts List
TH-65PX600U 17.2. Electrical Replacement Parts Ref. No. Part No. Part Name & Remarks Description List C1602-24 F1G1A104A012 C 0.01UF, K, 10V C1625 F1J0J1060004 C 0.010UF, K, Note: C1626-48 F1G1A104A012 C 0.01UF, K, 10V All parts except parts mentioned [PAVCA] in the Remarks...
Page 169 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description C2390 ECJ1XF1C104Z C 0.1UF, Z, 16V C2731 ECJ1VF1H104Z C 0.1UF, Z, 50V C2391 F1H1C104A065 C 0.1UF, K, 16V C2732 ECA1CMH101 E 100UF, 16V...
Page 170 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description C4178 ECJ1XB1C393K C 0.039UF, K, C4307-09 F1G1A104A012 C 0.01UF, K, 10V C4311 F1G1A104A012 C 0.01UF, K, 10V C4180 F1H1C104A065 C 0.1UF, K, 16V...
Page 171 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description C4417 F2G0J470A019 E 47UF 6.3V C4523 F1G1C103A048 C 0.010UF, K, C4418,19 ECJ1VB1A105K C 0.01UF, Z, 50V C4524 F1G1A104A012 C 0.01UF, K, 10V...
Page 172 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description C8073 ECJ0EB1A104K C 0.1UF, K, 10V C8185 ECJ2FF1A475Z C 4.7UF, Z, 10V C8074 ECJ0EB1C103K C 0.010UF, K, C8186 EEEHB0G101R C 100PF, J, 4V...
Page 173 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description C8291 F1J1A106A043 C 0.010UF, K, C8416 EEFUD0J101ER E 100UF PAVCA C8417 F2G0J470A019 E 47UF 6.3V C8292 ECJ0EB1A104K C 0.1UF, K, 10V...
Page 174 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description C8526 EEEHB1C470P C 47PF, J, 16V C9548 ECJ1XB1C104K C 0.1UF, Z, 16V C8527 ECGRL0G680ER C 68PF, J, 4V C9552 ECJ1XB1C104K C 0.1UF, Z, 16V...
Page 175 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description D2520A LN1271RALTR D9110 B0JCGD000002 DIODE D2524 MA8056-M ZENER DIODE D9300-05 MA152K DIODE D2581 MA3043M ZENER DIODE D9800 B0JCME000037 DIODE D2582 MA3056M...
Page 176 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description IC1105,06 C0JBAS000128 IC8057 C0DBAYY00054 IC1107 TVRP080S PAVCA IC8202 C0JBAS000245 IC1108 C0EBF0000354 IC8203,04 C0JBAS000223 IC1110 C0CBCAD00016 IC8205 C0ABBA000025 IC1301,02 C3ZBN0000026 IC8206 C1AB00002471...
Page 177 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description JS4033-40 ERJ2GE0R00 M 0.0 OHM, L5609 G0A220GA0002 CHOKE COIL J,0.063W L5612 TALL08N2R7MA INDUCTION COIL JS4042,43 ERJ2GE0R00 M 0.0 OHM, L5615 TALL08N150KA INDUCTION COIL J,0.063W...
Page 178 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description K1KA05AA0192 5P CONNECTOR Q8201 B1ABDF000034 TRANSISTOR K1KA05AA0193 5P CONNECTOR Q8203 B1BBAB000039 TRANSISTOR K1KA11AA0194 11P CONNECTOR Q8207 B1ABDF000034 TRANSISTOR PA10 K1KA06A00452 6P CONNECTOR...
Page 179 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R1166,67 ERJ2GEJ101 M 100 OHM, R1249 ERJ2GEJ103 M 10KOHM, J,0.063W J,0.063W R1168 ERJ2GE0R00 M 0.0 OHM, R1250 ERJ2GEJ474 M 470KOHM, J,0.063W J,0.063W...
Page 180 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R1356,57 ERJ2GEJ100 M 10 OHM, R1470 ERJ2GE0R00 M 0.0 OHM, J,0.063W J,0.063W R1363 ERJ2GEJ473 R1472,73 D1HG8208A002 NETWORK RESISTER 47KOHM,J,0.063W R1474 ERJ8GEY0R00...
Page 181 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R1629 ERJ2GEJ472 M 4.7KOHM, R1718 EXB2HV220JV RESISTOR ARRAY J,0.063W R1719,20 ERJ2GEJ220 M 22 OHM, R1631 ERJ2GEJ221 M 220 OHM, J,0.063W J,0.063W...
Page 182 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R2321 ERJ3GEYJ470 M 47 OHM,J,1/16W R2625 ERJ3GEYJ221 M 220 OHM,J,1/16W R2323 ERJ3GEYJ470 M 47 OHM,J,1/16W R2642 ERJ3GEYJ101 M 100 R2330 ERJ6GEYJ100...
Page 183 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R2756 ERJ3GEYJ220 M 22 OHM,J,1/16W R2868,69 ERJ6ENF75R0 M 75 OHM, 1/10W R2757 ERJ3GEYJ471 M 470 R2871 ERJ3GEYJ393 M 39KOHM,J,1/16W OHM,J,1/16W R2894...
Page 184 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R4132,33 ERJ2GEJ103 M 10KOHM, R4534,35 ERJ2GEJ101 M 100 OHM, J,0.063W J,0.063W R4257 ERJ3EKF3302 M 33KOHM, 1/16W R4536-38 ERJ3EKF1500 M 150 OHM, 1/16W...
Page 185 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R4661 ERJ2GEJ472 M 4.7KOHM, R4796 EXB2HV470JV RESISTOR ARRAY J,0.063W R4804 ERJ2GEJ101 M 100 OHM, R4662 ERJ2GEJ220 M 22 OHM, J,0.063W J,0.063W...
Page 186 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R5647 ERJ3GEYJ221 M 220 R8062,63 ERJ6GEYJ220 M 22 OHM,J,1/10W OHM,J,1/16W R8064 EXB38V560J RESISTOR ARRAY R5648 ERJ3GEYJ103 M 10KOHM,J,1/16W R8067 EXB38V103J RESISTOR ARRAY...
Page 187 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R8192 ERJ2GEJ472 M 4.7KOHM, R8261 ERJ2GEJ103 M 10KOHM, J,0.063W J,0.063W R8194,95 ERJ2GE0R00 M 0.0 OHM, R8264,65 ERJ2GEJ221 M 220 OHM, J,0.063W J,0.063W...
Page 188 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R8342,43 ERJ2GEJ560 M 56 OHM, R8428 ERJ2GEJ103 M 10KOHM, J,0.063W J,0.063W R8344 ERJ2GE0R00 M 0.0 OHM, R8429,30 ERJ2GEJ472 M 4.7KOHM, J,0.063W J,0.063W...
Page 189 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R8501,02 ERJ2GEJ103 M 10KOHM, R8576 ERJ2GE0R00 M 0.0 OHM, J,0.063W J,0.063W R8503 ERJ3EKF1002 M 10KOHM, 1/16W R8577 ERJ3EKF6802 M 68KOHM, 1/16W...
Page 190 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R8706 ERJ2GEJ103 M 10KOHM, R9099 ERJ3GEYJ101 M 100 J,0.063W OHM,J,1/16W R8707 ERJ2GEJ473 R9101 ERJ3GEYJ103 M 10KOHM,J,1/16W 47KOHM,J,0.063W R9102 ERJ3GEYJ101 M 100...
Page 191 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R9244,45 ERJ3GEYJ101 M 100 R9543,44 ERJ3GEYJ103 M 10KOHM,J,1/16W OHM,J,1/16W R9545 ERJ3GEYJ304V R9247,48 ERJ3GEYJ472 300KOHM,J,1/16W 4.7KOHM,J,1/16W R9548-50 ERJ3GEYJ103 M 10KOHM,J,1/16W R9367 ERJ6GEYJ181...
Page 192 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R9848,49 EXB2HV470JV RESISTOR ARRAY K1MN80BA0076 80P CONNECTOR R9850 ERJ3GEYJ473 M 47KOHM,J,1/16W K1KA08AA0150 8P CONNECTOR R9854 ERJ3GEYJ101 M 100 K1KA20AA0009 20P CONNECTOR...
Page 193 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description C6524,25 F1L1E4750004 C 4.7UF, 25V C6938 ECJ2XB1H102K C 1000PF, K, 50V C6527 F1L1E4750004 C 4.7UF, 25V C6940 ECJ2FB1H104K C 0.1UF, K, 50V...
Page 194 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description C7406 ECJ1XB1C104K C 0.1UF, Z, 16V D6110 MA111 DIODE C7412-15 ECJ1XB1C104K C 0.1UF, Z, 16V D6112 MA8330M ZENER DIODE C7418,19 TCUY1C105ZFN...
Page 195 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description D6723,24 B0JCME000037 DIODE IC6753 C0JBAB000715 D6725 B0ECHP000003 DIODE IC6771 C0CBADC00089 D6726-33 MA8056H ZENER DIODE IC6772 C0ZBZ0001325 D6734 MA111 DIODE IC6773,74 C0JBAA000377...
Page 196 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description Q6103 B1ABNF000006 TRANSISTOR Q6662 2SD601A TRANSISTOR Q6104 B1ADNF000006 TRANSISTOR Q6665 B1ABNF000006 TRANSISTOR Q6105-08 B1DFKM000002 TRANSISTOR Q6671-75 B1DFES000003 TRANSISTOR Q6111,12 B1DFKM000002 TRANSISTOR...
Page 197 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R6102 D0GD101JA059 M 100 R6252,53 ERJ6ENF3902 M 39KOHM, 1/10W OHM,J,0.25W R6254 ERJ6ENF6801 M 6.8KOHM, 1/10W R6104 D0GD101JA059 M 100 R6255 ERJ6ENF1201 M 1.2KOHM, 1/10W...
Page 198 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R6585,86 ERJ6ENF1501 M 1.5KOHM, 1/10W R6688 ERJ6GEYJ472 4.7KOHM,J,1/10W R6587 ERJ6GEYJ222 2.2KOHM,J,1/10W R6689 D0GD100JA059 M 10 OHM,J,0.25W R6588 ERJ6GEYJ103 M 10KOHM,J,1/10W R6690...
Page 199 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R6833-36 ERJ6ENF5102 M 51KOHM, 1/10W R7143-45 EXB38V681J RESISTOR ARRAY R6837 ERJ6ENF5602 M 56KOHM, 1/10W R7146,47 EXB38V470J RESISTOR ARRAY R6839 ERJ6GEYJ472 R7148,49...
Page 200 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R7358-65 D0GZ6R8JA020 M 6.8 OHM,J, PAVCA R7562,63 EXB38V470J RESISTOR ARRAY 0.5W R7564,65 EXB38V681J RESISTOR ARRAY R7366,67 ERJ3GEYJ470 M 47 OHM,J,1/16W R7567...
Page 201 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description SS21 K1KA07A00170 7P CONNECTOR C552 KZE1A152 ELECTROLYTIC PAVCA CAPACITOR SS2MM1,M2 TMME190 CLAMPER C555 TBB474K2 CERAMIC CHIP SS23 K1KB07AA0087 7P CONNECTOR CAPACITOR...
Page 202 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R407 ERJ6ENF2372 M23.7KOHM, 1/10W MC301 MLZNC102 MODULE PAVCA R408 MPC2WR05K METAL PLATE PAVCA RESISTOR MC401 MLLSB103 MODUIE PAVCA R410 ERJ6GEYJ101 M 100...
Page 203 TH-65PX600U Ref. No. Part No. Part Name & Remarks Ref. No. Part No. Part Name & Remarks Description Description R1752 ERJ6GEYJ183 M 18KOHM,J,1/10W R1753 ERJ6GEYJ103 M 10KOHM,J,1/10W K1601 DG12D1-0 RELAY R1754 ERJ6GEYJ473 M 47KOHM,J,1/10W K1602 DJ12D2-0 RELAY R1755 ERJ6GEYJ103 M 10KOHM,J,1/10W...
Page 204 TH-65PX600U Ref. No. Part No. Part Name & Remarks Description R276 ERJ6ENF1003 M 100KOHM, 1/10W R277 ERDS1TJ472 C 4.7KOHM, J,1/2W R278-82 ERDS1TJ622 CARBON FILM PAVCA RESISTOR R283 ERJ6ENF2212 M22.1KOHM, 1/10W R1601 R5B100J 5W 10 OHM R1602 ERC12UGK185 S 1.8MOHM, K,1/2W...
Page 205 ORDER NO.ITD0610080PE B19, B34 Canada: D10, B07 TH-65PF9BK TH-65PF9EK TH-65PF9UK TH-65PX600U Please revise the original parts list in the Service Manual to conform to the change(s) shown herein. If new part numbers are shown, be sure to use then ordering parts.
Page 206 TH-65PF9TK TH-65PF9UK TH-65PF9WK TH-65PV600A TH-65PV600C TH-65PV600E TH-65PV600M TH-65PV600R TH-65PX600B TH-65PX600E TH-65PX600U Please revise the original parts list in the Service Manual to conform to the change(s) shown herein. If new part numbers are shown, be sure to use then ordering parts.

Panasonic TH-65PX600U Service Manual

1 Applicable Signals

2 Safety Precautions

3 Prevention of Electro Static Discharge (ESD) to Electrostatically Sensitive (ES) Devices

4 About Lead Free Solder (Pbf)

5 Service Hint

6 Plasma Panel Replacement Method

7 Caution Statement

8 Location of Lead Wiring

9 Self-Check Function

10 Serviceman Mode

11 Adjustment Procedure

12 Adjustment

13 Hotel Mode

14 Conductor Views 14.1. P-Board

15 Schematic and Block Diagram

16 Parts Location & Mechanical Replacement Parts List

17 Electrical Replacement Parts List

Quick Links

Specifications

Related Manuals for Panasonic TH-65PX600U

Summary of Contents for Panasonic TH-65PX600U