Table of Contents
Advertisement
Quick Links
Installation Instructions
Installer:
Owner:
L
WARNING: If the information in this manual is not followed exactly, a fire or
!
explosion may result causing property damage, personal injury or death.
L
AVERTISSEMENT: Si l'information dans ce manuel n'est pas suivie exactement,
!
une incendie ou une explosion peut résulter, entrainant des dégats matériels, des
blessures ou la mort.
and
Owner's Manual
Thermador
Outdoor Cooktop
Model SB2B
Please leave these instructions with the unit for the owner.
Please retain these instructions for future reference.
for
Advertisement
Table of Contents
Related Manuals for Thermador SB2B
Summary of Contents for Thermador SB2B
-
Page 1: Installation Instructions
WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or death. AVERTISSEMENT: Si l’information dans ce manuel n’est pas suivie exactement, une incendie ou une explosion peut résulter, entrainant des dégats matériels, des blessures ou la mort. Thermador Model SB2B... - Page 2 A Special Message to Our Customers Thank you for selecting the Thermador® Outdoor Cooktop. We recom- mend that you take time to read this entire booklet before using your new appliance for the first time. This booklet contains important safety information, installation instructions, operation and care suggestions.
-
Page 3: Table Of Contents
Contents SECTION 1: Safety Information ... 2-4 SECTION 2: Gas Requirements ... 5 Natural Gas Requirements ... 5 Propane Gas Requirements ... 5 Gas Consumption ... 5 SECTION 3: Site Preparation... 6 Built-In Installations ... 6 Cabinet Preparation ... 6 SECTION 4: Electrical Cautions ... -
Page 4: Safety Information
SECTION 1: SAFETY INFORMATION FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. If odor continues, immediately call your gas supplier or your fire department. FOR YOUR SAFETY 1. Do not store or use gasoline or other flam- mable vapors and liquids in the vicinity of this or any other appliance. - Page 5 Replacement hose assemblies can be purchased at barbecue supply stores, or ordered through Thermador®. If purchased at a retail outlet, the hose assembly must be identical to the one supplied with the unit. To inspect the hose assembly, check under the unit through access opening in the enclosure.
-
Page 6: Important Safety Instructions
SECTION 1: SAFETY PRACTICES TO AVOID PERSONAL INJURY IMPORTANT SAFETY INSTRUCTIONS READ ALL INSTRUCTIONS BEFORE USING YOUR COOKTOP LP TANK REQUIREMENTS This model can be converted for use with an LP cylinder which can be purchased locally from an LP supplier or other retail outlet. -
Page 7: Gas Requirements
Inlet Connection: 1/2" NPT Supply Pressure: 11" to 14" W.C. Manifold Pressure: 10" W.C. GAS CONSUMPTION The total gas consumption of the Thermador Cooktop with all burners on "HI" is 30,000 BTU/HR. CAUTION The appliance must be isolated from the gas... -
Page 8: Site Preparation
2" x 4" x 18" WOOD SUPPORT CABINET PREPARATION The model SB2B is designed for easy installation into masonry enclosures. For noncombustible applications, the cooktop drops into the opening shown in Figure 1 (below). A ledge is required to support the cooktop from the bottom. -
Page 9: Electrical Cautions
CAUTION The Thermador® Outdoor Cooktop uses an electronic ignition system that requires a 120 VAC, 15A, 60 Hz power supply. A properly grounded duplex outlet must be provided adjacent to the lower left rear corner of the unit. -
Page 10: Unpacking, Moving And Placing The Unit
(not supplied) CONVERSION FROM NATURAL GAS TO LP (LIQUID PROPANE) Model SB2B is manufactured at the factory for use with natural gas, and as such requires conversion for use with an LP gas supply. The conversion should be done by a qualified technician or your gas supplier. All orifices required for conversion are provided with the unit. - Page 11 SECTION 5: UNPACKING AND PLACING THE UNIT FIGURE 7 5. The bypass jet must be turned clockwise with a small flat-bladed screwdriver until fully seated to set proper low flow rate. See Figures 7 and 8, above. The cooktop is supplied with a pressure regulator that is packed with the unit.
-
Page 12: Liquid Propane Hook-Up
7. If the cooktop will be used with an LP cylinder, follow these steps: A. The Model LPHose is available at your Thermador dealer. B. This assembly can also be purchased locally providing it meets the following specifications: Hose length to be 24". -
Page 13: Test And Adjustment
SECTION 6: TEST AND ADJUSTMENT GAS AND ELECTRICAL HOOK-UP With the unit inside of the enclosure, connect the gas supply hose to the manual shut-off valve and open valve. Check the connection points at the shut-off valve for any leaks and repair prior to installation of the unit. -
Page 14: Installer Checklist
SECTION 6: TEST AND ADJUSTMENT INSTALLATION — Placement of unit. — Specified clearances maintained to combustible or noncombustible surfaces as applicable. — The burner box area is free of any packing materials and that the burners are properly located and installed. —... -
Page 15: Using Your Outdoor Cooktop
SECTION 7: USING YOUR OUTDOOR COOKTOP GENERAL BURNER INFORMATION • Each burner is rated at 15,000 BTU on High. • Choose a pan base to fit the flame size. The flame should never extend beyond the base of the pan. •... -
Page 16: Care And Cleaning
SECTION 8: CARE AND CLEANING PART and MATERIAL Exterior Finish/Cover Stainless Steel Grates Porcelain Enamel on Cast Iron Burner Ports and Caps Aluminum / Porcelain Control Knobs, Bezels Plastic / Chrome SUGGESTED CARE The quality of this material resists most stains and pitting, providing the surface is kept clean and protected with a stainless steel polish. -
Page 17: Service
SECTION 9: SERVICE Troubleshooting Power Failure - In the event of a power failure, the Thermador the burners with a match. If Burners Fail to Ignite - If the burners fail to ignite verify that the unit is connected to a properly grounded duplex outlet. -
Page 18: Warranty
Factory Authorized Service Agency during normal working hours. For a Service Agency nearest you, please call 800/735-4328. Thermador Will Not Pay For: 1. Service by an unauthorized agency. Damage or repairs due to service by an unauthorized agency or the use of unauthorized parts. - Page 19 Thermador reserves the right to change specifications or design without notice. Some models are certified for use in Canada. Thermador is not responsible for products which are transported from the United States for use in Canada. Check with your local Canadian distributor or dealer. Thermador, 5551 McFadden Avenue, Huntington Beach, CA 92649.